TROUbLESHOOTING | ||
|
|
|
| Observe all Safety Guidelines detailed throughout this manual |
|
|
|
|
PRObLEMS
(SYMPTOMS)
POSSIbLE
CAUSE
RECOMMENDED
COURSE OF ACTION
| Engine will not go to high idle when | 1. Broken wire in auxiliary current |
|
|
| ||||
| using auxiliary power. |
| sensor wiring. |
|
|
| |||
|
|
| 2. | Auxiliary power load is less than |
|
|
| ||
|
|
|
| 100 watts. Idler may not respond |
|
|
| ||
|
|
|
| with less than a 100 watt load. Set |
|
|
| ||
|
|
|
| idler to "High". |
|
|
| ||
|
|
| 3. | Faulty PC board. |
|
|
| ||
|
|
|
|
|
|
|
| ||
| Engine will not go to high idle | 1. | Faulty PC board or Engine ECU. |
|
|
|
| ||
| under weld or auxiliary loading. |
|
|
|
|
|
|
| |
|
|
|
|
|
|
|
| ||
| Engine does not develop full | 1. | Fuel filter clogged, Replace. |
|
|
|
| ||
| power. Engine runs rough. | 2. | Air filter clogged, clean or replace. |
|
|
| |||
|
|
| 3. | Valves out of adjustment. |
|
|
| ||
|
|
| 4. | Fuel contaminated with water or |
|
|
| ||
|
|
|
| sediment. Check water separator |
|
|
| ||
|
|
|
| and empty of water, bleed fuel |
|
|
| ||
|
|
|
| system. Replace fuel in tank if |
|
|
| ||
|
|
|
| needed. |
|
|
| ||
|
|
|
|
|
|
| If all recommended possible | areas | |
|
|
|
|
|
|
| |||
| Engine will not go to high idle when | 1. | Faulty PC board or Engine ECU. |
| of misadjustment have | been | |||
| attempting to weld or using auxil- |
|
|
|
| checked and the problem persists, | |||
| iary power. Switching to manual |
|
|
|
| Contact your local Lincoln | |||
| high idle does not work. |
|
|
|
| Authorized Field Service Facility. | |||
|
|
|
|
|
|
| |||
| Engine will not shut off. | 1. | Fuel Shutdown solenoid not func- |
|
|
|
| ||
|
|
|
| tioning properly / linkage binding. |
|
|
| ||
|
|
|
| Stop engine by shutting off valve |
|
|
| ||
|
|
|
| located on main fuel filter. Contact |
|
|
| ||
|
|
|
| authorized local Engine Service |
|
|
| ||
|
|
|
| Shop. |
|
|
| ||
|
|
|
|
|
|
| |||
Engine does not develop full power. | 1. Fuel filter dirty/clogged. Replace. |
|
|
|
| ||||
Low weld and auxiliary output. | 2. Air filter dirty/clogged. Replace Air |
|
|
| |||||
Engine runs rough. |
| Filter Element. |
|
|
| ||||
|
|
| 3. Fouled fuel injector(s). Contact |
|
|
| |||
|
|
|
| authorized Engine Service Shop. |
|
|
| ||
|
|
| 4. Fuel contaminated with water. |
|
|
| |||
|
|
|
| Check water separator for water. |
|
|
| ||
|
|
|
| Clean and replace as needed. |
|
|
| ||
|
|
|
| Replace fuel in tank. |
|
|
| ||
|
|
| 5. Cracked or loose fuel hose. |
|
|
| |||
|
|
|
| Replace hose and tighten clamps. |
|
|
| ||
|
|
| 6. Valves out of adjustment. Contact |
|
|
| |||
|
|
|
| authorized local Engine Service |
|
|
| ||
|
|
|
| Shop. |
|
|
| ||
|
|
|
|
|
|
|
|
|
|
|
|
|
| CAUTION |
|
| |||
If for any reason you do not understand the test procedures or are unable to perform the tests/repairs safely, contact your Local Lincoln Authorized Field Service Facility for technical troubleshooting assistance before you proceed.
AIR VANTAGE® 500 KUbOTA
