Louisville Tin and Stove CF354C-H Contents, Introduction, Counterflow Wall Furnace Specifications

CONTENTS

Contents……………………………………………........... 2		Lighting & Re-Lighting Instructions……………….. 10,11
Introduction…………………………………………. 2		Operation………………………………………….....….	12
Specifications………………………………………..	2	Terminal Block Wiring Diagram……………….....…… 13
Safety Rules…………………………………………	3	Manual Reset…………………………………....……..	13
Helpful Installation Information……………….........….	3	Maintenance Instructions…………………….………	13
Connecting the Vent……………………………....…..… 3,4		Wiring Diagram……………………………….....…….. 14,15
Combustion and Ventilation Air	5	Side & Rear Discharge Kits……………………...……16,17
Furnace Location………………………………….....….	6	Trouble Shooting Chart…………………………..….. 18,19
Rough-In Instructions…………………………..…..…. 6,7		Repair Parts (break down)………………………..….. 20-24
Installation……………………………………….......…..	8	Repair Parts List…………………………………....…. 21-25
Controls…………………………………………........…..	9	Warranty………………………………………….....….	27
Pilot Flame Adjustment…………………………......…..	9

INSTALLER MUST LEAVE THESE INSTRUCTIONS WITH THE CONSUMER, HAVE THEM COMPLETE, AND RETURN THE WARRANTY CARD.

INTRODUCTION

THIS IS A GAS-FIRED, GRAVITY VENTED WALL FURNACE THAT WILL OPERATE SAFELY AND PROVIDE AN EFFICIENT SOURCE OF HEAT WHEN INSTALLED, OPERATED AND MAINTAINED AS RECOMMENDED IN THESE INSTALLATION AND OPERATING INSTRUCTIONS. READ THESE INSTRUCTIONS THOROUGHLY BEFORE INSTALLING, SERVICING, OR USING THE APPLIANCE. IF YOU DO NOT UNDERSTAND ANY PART OF THESE INSTRUCTIONS CONSULT LOCAL AUTHORITIES, OTHER QUALIFIED INSTALLERS, SERVICE AGENCIES, THE GAS SUPPLIER, OR THE MANUFACTURER.

COUNTERFLOW WALL FURNACE SPECIFICATIONS

Your counterflow wall furnace is packed in a single carton that also includes thermostat, thermostat wire, and insulated staples. The thermostat, wire, and staples are packed in the burner compartment and are accessible by removing the burner access door. While the burner access door is open, check the rating plate to verify that the model number is correct and that the wall furnace is equipped for the type gas you intend to use.

			Vent						Approx.
Model Type	Type	BTU/HR.	Size	Gas		Blower			Shipping
Number Control	Gas	Input	(Oval)	Inlet	Finished Dimensions	Speed	Amps	CFM	Weight
	MODELS WITH LOW-BTU STANDING PILOT
CF353C-H 24 Volt Nat.		35,000	4”	½”	14-5/16”Wx10¼”Dx78-5/8”H	1	1.95	320	95	Lbs.
CF354C-H 24 Volt L.P.		35,000	4”	½”	14-5/16”Wx10¼”Dx78-5/8”H	1	1.95	320	95	Lbs.
CF503C-H 24 Volt Nat.		50,000	4”	½”	14-5/16”Wx10¼”Dx81-5/16”H	2	2.25	440	104 Lbs.
CF504C-H 24 Volt L.P.		50,000	4”	½”	14-5/16”Wx10¼”Dx81-5/16”H	2	2.25	440	104 Lbs.
CF653C-H 24 Volt Nat.		65,000	4”	½”	14-5/16”Wx10¼”Dx87-5/16”H	2	2.25	440	107 Lbs.
CF654C-H 24 Volt L.P.		65,000	4”	½”	14-5/16”Wx10¼”Dx87-5/16”H	2	2.25	440	107 lbs.
		MODELS WITH INTERMITTENT IGNITION
CF357C-H 24 Volt Nat.		35,000	4”	½”	14-5/16”Wx10¼”Dx78-5/8” H	1	2.2	320	95	Lbs.
CF358C-H 24 Volt L.P.		35,000	4”	½”	14-5/16”Wx10¼”Dx78-5/8”H	1	2.25	320	95 Lbs.
CF557C-H 24 Volt Nat.		55,000	4”	½”	14-5/16”Wx10¼”Dx87-5/16”H	2	2.5	440	107 Lbs.
CF558C-H 24 Volt L.P.		55,000	4”	½”	14-5/16”Wx10¼”Dx87-5/16”H	2	2.55	440	107 Lbs.

Page 2