Manuals / Louisville Tin and Stove / Household Appliance / Furnace

Louisville Tin and Stove CF504C-H, CF654C-H, CF354C-H Counterflow Wall Furnace / Standing Pilot

Models: CF354C-H CF654C-H CF353C-H, CF503C-H, CF653C-H, CF354C-H, CF504C-H, CF654C-H, CF357C-H, CF557C-H, CF358C-H, CF558C-H CF504C-H

1 27

Download 27 pages 32.19 Kb

Page 20

Image 20

COUNTERFLOW WALL FURNACE / STANDING PILOT

Prices and specifications subject to change without notice. All prices are F.O.B. factory.

MODELS:
NAT. GAS	L.P. GAS
CF353C-H	CF354C-H
CF503C-H	CF504C-H
CF653C-H	CF654C-H

6	46

USE ONLY FACTORY SUPPLIED

REPLACEMENT PARTS

32c

52 1a

32 15

4526

252

32b

34b

32d

10 19

811

29 28

22/23 16

CONTROL ASSEMBLY

REV. 03/05

Page 20

42 36

17/18

Mr. Contractor, we only sell parts through our wholesalers, but the prices listed are for your convenience. For prompt parts service, contact the wholesaler from which you purchased your Cozy heater. NOTE: Parts & schematic drawings on current models are shown at www.cozyheaters.com.

Page 20

Image 20

Louisville Tin and Stove CF504C-H, CF654C-H, CF354C-H operating instructions Counterflow Wall Furnace / Standing Pilot

Contents

MODEL NUMBERS WHAT TO DO IF YOU SMELL GASØDo not try to light any appliance INSTALLATION AND OPERATING INSTRUCTIONSCONTENTS COUNTERFLOW WALL FURNACE SPECIFICATIONSINTRODUCTION MODELS WITH LOW-BTUSTANDING PILOTVENTING SAFETY RULESREAD CAREFULLY BEFORE INSTALLING UNIT FIGURE A personal injury or possible deathPage ELECTRICAL ROUGH-IN LOCATION AND SPECIAL PRECAUTIONSROUGH-ININSTRUCTIONS GAS ROUGH-IN INSTALLATION WHEN INSTALLED FLUSH TO WALL INSTALLATION / WHEN RECESSED UP TO 9-1/4”PILOT ADJUSTMENT PILOT FLAME ADJUSTMENTNATURAL GAS L.P. GASFOR YOUR SAFETY READ BEFORE LIGHTING STANDING PILOTLIGHTING INSTRUCTIONS TO TURN OFF GAS TO APPLIANCEFOR YOUR SAFETY READ BEFORE LIGHTING LIGHTING INSTRUCTIONSTO TURN OFF GAS TO APPLIANCE WHAT TO DO IF YOU SMELL GASPROPER BURNER FLAME OPERATION5” to 7” FIGURE11AUXILIARY LIMIT SWITCH MAINTENANCE INSTRUCTIONSTERMINAL BLOCK WIRING DIAGRAM MOTOR WhiteSCHEMATIC CF353C-H, CF354C-HSTANDING PILOT CF503/504C-H, CF653/654C-H CF353C-HCF357C-H, CF358C-H I.I.DCF557C-H, CF558C-H CF357C-H, CF358C-HOPTIONAL ACCESSORY KITS ROUGH-INSFOR REAR OR SIDE DISCHARGEREAR REGISTER KIT Flush Mount See Figure REAR DISCHARGE KIT RecessedSIDE DISCHARGE ON CASING OPTIONAL KITS - CONTINUEDSIDE DISCHARGE With Extension Boot TROUBLE SHOOTING CHART - PILOT AND VALVE SYMPTOMPOSSIBLE CAUSES CORRECTIVE ACTIONSYMPTOM POSSIBLE CAUSESCORRECTIVE ACTION POSSIBLE CAUSESCOUNTERFLOW WALL FURNACE / STANDING PILOT REV. 03/05 REQUIRES TWOPage MARCHASSEMBLY CONTROLCOUNTERFLOW WALL FURNACE / I.I.D. PILOT NAT. GAS L.P. GAS24 VOLT SYSTEM WITH INTERMITTENT BOOT - FLUSH W/BOOTKIT NO. 31300-A VENTREV. 03/05 MARCHYOUR GAS CONTROL AND PILOT LIGHT SYSTEM SYSTEM FOR HEATING EQUIPMENTWHAT YOU DON’T KNOW CANHURT YOU TABLE A LOUISVILLE TIN AND STOVE COMPANYLIMITED WARRANTY