DCA-70SSJU— RULES FOR SAFE OPERATION
■NEVER Run engine without air filter. Severe engine damage may occur.
■ALWAYSservice air cleaner frequently to prevent engine malfunction.
■ALWAYS disconnect the negative battery terminal before performing service on the generator.
■ALWAYS be sure the operator is familiar with proper safety precautions when operating the generator set.
■ALWAYS store equipment properly when not in use.
■DO NOT leave the generator running in the manual mode unattended.
■DO NOT allow unauthorized people to operate this equipment.
■ALWAYS read, understand, and follow procedures in Operator’s Manual before attempting to operate equipment.
■Refer to the John Deere Engine Owner's Manual for engine technical questions or information.
DANGER:
Pay close attention to ventilation when operating the generator inside tunnels and caves. The
engine exhaust contains noxious elements. Engine exhaust must be routed to a ventilated area.
Generator Grounding
To guard against electrical shock and possible damage to the equipment, it is important to provide a good EARTH ground.
Article 250 (Grounding) of the National Electrical Code (NEC) provides guide lines for proper grounding and specifies that the cable ground shall be connected to the grounding system of the building as close to the point of cable entry as practical.
ALWAYS be sure to use the ground terminal (green wire) when connecting a load to the UVWO output terminals.
Battery
The battery contains acids that can cause injury to the eyes and skin.To avoid eye irritation, always wear safety glasses. Use well insulated gloves when picking up the battery. Use the following guidelines when handling the battery:
1.DO NOT drop the battery. There is the possibility of risk that the battery may explode.
2.DO NOT expose the battery to open flames, sparks, cigarettes etc. The battery contains combustible gases and liquids. If these gases and liquids come in contact with a flame or spark, an explosion could occur.
3.ALWAYS keep the battery charged. If the battery is not charged a buildup of combustible gas will occur.
4.ALWAYS keep battery charging and cables in good working condition. Repair or replace all worn cables.
5.ALWAYS recharge the battery in an vented air environment, to avoid risk of a dangerous concentration of combustible gases.
6.In case the battery liquid (dilute sulfuric acid) comes in contact with clothing or skin, rinse skin or clothing immediately with plenty of water.
7.In case the battery liquid (dilute sulfuric acid) comes in contact with your eyes, rinse eyes immediately with plenty of water, then contact the nearest doctor or hospital, and seek medical attention.
Transporting
■ALWAYS shutdown engine before transporting.
■Tighten both fuel tank caps securely.
■If generator is mounted on a trailer, make sure trailer complies with all local and state safety transportation laws. See next page “Towing Safety Precautions” for basic towing techniques.
PAGE 12 —
