Safety Information
engine saFeTY
Danger
The engine fuel exhaust gases contain poisonous carbon monoxide. This gas is colorless and odorless, and can cause death if inhaled.
The engine of this equipment requires an adequate free fl ow of cooling air. never
operate this equipment in any enclosed or narrow area where free fl ow of the air is
restricted. If the air fl ow is
restricted it will cause injury to people and property and serious damage to the equipment or engine.
Warning
Do noT place hands or fingers inside engine compartment when engine is running.
never operate the engine with heat shields or guards removed.
Keep fi ngers, hands hair and clothing away 
from all moving parts to prevent injury.
Do noT remove the radiator cap while the 
engine is hot. High pressure boiling water 
will gush out of the radiator and severely 
scald any persons in the general area of 
the generator.
Do noT remove the coolant drain plug while the engine is hot. Hot coolant will gush out of the coolant tank and severely scald any persons in the general area of the generator.
Do noT remove the engine oil drain plug while the engine is hot. Hot oil will gush out of the oil tank and severely scald any persons in the general area of the generator.
CaUTion
never touch the hot exhaust manifold,
muffl er or cylinder. Allow these parts to cool before servicing equipment.
NOTICE
never run engine without an air fi lter or with a dirty air fi lter. Severe engine damage may occur. Service air fi lter frequently to prevent engine malfunction.
never tamper with the factory settings of the engine or engine governor. Damage to the engine or equipment can result
if operating in speed ranges above the 
maximum allowable.
Wet stacking is a common problem with diesel engines which are operated for extended periods with light or no load applied. When a diesel engine operates without suffi cient load (less than 40% of the rated output), it will not operate at its optimum temperature. This will allow unburned fuel to accumulate in the exhaust system, which can foul the fuel injectors, engine valves and exhaust system, including turbochargers, and reduce the operating performance.
In order for a diesel engine to operate at peak effi ciency, it must be able to provide fuel and air in the proper ratio and at a high enough engine temperature for the engine to completely burn all of the fuel.
Wet stacking does not usually cause any permanent damage and can be alleviated if additional load is applied to relieve the condition. It can reduce the system performance and increase maintenance. Applying an increasing load over a period of time until the excess fuel is burned off and the system capacity is reached usually can repair the condition. This can take several hours to burn off the accumulated unburned fuel.
State Health Safety Codes and Public Resources Codes specify that in certain locations, spark arresters must be used on internal combustion engines that use hydrocarbon fuels. A spark arrester is a device designed to prevent accidental discharge of sparks or fl ames from the engine exhaust. Spark arresters are qualifi ed and rated by the United States Forest Service for this purpose. In order to comply with local laws regarding spark arresters, consult the engine distributor or the local Health and Safety Administrator.
page 8 — DCA40sskU/ku4i 60 hz Generator • operation and parts manual — rev. #1 (03/11/13)
