Foot REST, Left, PANEL, Front HTH/STH, Frame | Multiquip HTH44T

HTH44T— FRAME AND FUELTANK ASSY.

FRAME AND FUEL TANK ASSY.
NO.	PART NO.	PART NAME	QTY.	REMARKS
1	11628	FOOT REST, LEFT	1
2	0202	SCREW, HHC 5/16- 18 X 1	2
3	0105	SCREW, HHC 5/16- 18 X 1 1/2	2
4	11678	PANEL, FRONT HTH/STH	1
5	11418	FUEL CAP/ GAUGE (10.5)	1
6	12025	SPACER, FUEL TANK	2
7	11922	TANK, 12 GALLON FUEL POLYETHYLENE	1
8	0300B	WASHER, FLAT 5/16 SAE	4
9	5283	NUT, NYLOC 5/16- 18	6
10	12021	BRACKET, FUEL TANK SUPPORT	2
11	20160	FRAME	1
12	19633	BUSHING, RUBBER FUEL	2
13	12006	FITTING, 90 03BARB- 4BARB FUEL	1
14	12010	SCREEN, FUEL (DAPCO 11656)	1
15	60058	HOSE, FUEL YELLOW 1/4 X 3/8 X 2"	1
17	12023	FITTING, 90 05BARB- 4BARB FUEL	1
18	11584	SIGHT GLASS, 3/4 MALE PIPE	1
19	12489	FLANGE GASKET	1
20	ZINFB04	BASE	1
21	ZINPS0014	SCREW, #10 - 32 1/2	6
22	12332	CAP, HYD 5PSI 10 MICRON	1
23	ZINFB15	JACK CHAIN, #16 SINGLE	1
24	ZINFB08	CHAIN RING	1
25	3233	WASHER, FENDER 1.50D X 3/8 ID	2

HTH44T • RIDE-ON POWER TROWEL — OPERATION & PARTS MANUAL — REV. #8 (03/27/12) — PAGE 77

Image 77

Multiquip HTH44T Foot REST, Left, PANEL, Front HTH/STH, Fuel CAP/ Gauge, SPACER, Fuel Tank, BRACKET, Fuel Tank Support

Contents

Model HTH44T Proposition 65WARNING SILICOSIS/RESPIRATORYWARNINGS HTH44T-TABLE of Contents Ordering parts has never been easier Parts Ordering Procedures Training Checklist HTH44T-TRAINING Checklist Daily PRE-OPERATION Checklist HTH44T- Daily PRE-OPERATION Checklist HTH44T- Safety Message Alert Symbols Over Speed Conditions Sight and Hearing hazard HTH44T- Safety Message Alert Symbols HTH44T- Rules for Safe Operation HTH44T- Operation and Safety Decals HTH-44T Specifications HTH44T- Specifications HTH44T- General Information HTH44T Controls and Indicators Front HTH44T- Controls and Indicators HTH44T Controls and Indicators Rear Fuel HTH44T- Initial START-UP HTH44T- Initial START-UP Engine Throttle Control Lever High Joystick Control Forward Direction Maintenance Schedule HTH44T- Maintenance Blade Pitch Adjustment Procedure Changing a Blade Pressure Gauge Hydraulic Pump Pressure Gauge Left Steering Valve Steering Pressure Adjustment HTH44T-TROUBLESHOOTING Wiring? HTH44T- Explanation of Code in Remarks Column Unit Pivot ASSY. Left HTH44T- Pivot ASSY. Left Bushing YokeRocker Block WASHER, Lock 3/8 MED Pivot ASSY. Right HTH44T- Pivot ASSY. Right SHAFT, Pivot TrunnionRETAINER, Clutch LEFT/RIGHT Twin Pitch Assy HTH44T-TWIN Pitch ASSY. LEFT/RIGHT HTH44T-TWIN Pitch ASSY. LEFT/RIGHT COVER, Pitch Cont Housing HOUSING, Pitch CONTROL, 1-3/4KEY, Woodruff #9 WASHER, Lock 5/16 MED SLEEVE, W/U-JOINT WASHER, FLAT, 5/16 SAESET COLLAR, 1/2 Miter BOX, Pitch Control Engine Kubota HTH44T- Engine Kubota ELEMENT, AIR Cleaner HOSE, AIR CleanerWASHER, LOCK, 1/2 MED SCREW, Drive #2- 3/16 U- Drive HTH44T- Engine Flange Kubota FLANGE, Nylon Bell HOUSING, KTRHUB, Hydraulic Pump MOUNT, Right Motor Engine Fuelkubota HTH44T- Engine Fuel Kubota WASHER, LOCK, 7/16 MED FILTER, Cannister Fuel Hydraulic Steering Left HTH44T- Hydraulic Steering Left TUBE, HYD. Steering Return TUBE, HYD. Steering PressureBELLOWS, STG. Cylinder PLATE, Bellows Mounting Hydraulic Steering Right HTH44T- Hydraulic Steering Right FITTING, 45 6MJ- 6MO Hose ASM, .38 ID X 17 STR EndsHose ASM, .38 ID X 15.5 STR. Ends NUT, HEX JAM Blkhd .5625-18UNF HTH44T- Steering Valve ASSY. Left Steering Valve Assembly Left CLAMP, Boot BOOT, LeftNUT, Special PLATE, Pivot Steering Valve Assembly Right RETAINER, Strg Valve Boot BOOT, RightFITTING, 45 6MJ-6MO FITTING, TEE 6MJ-6MO-6MJ Palm Handles Left and Right HTH44T- Palm Handles Left and Right TUBE, Handle Switch HANDLE, Palm W/ SWITCH, LeftSwitch ASM Valve ASM, Steering Left Hydraulic Drive Assembly HTH44T- Hydraulic Drive Assembly FITTING, 90 IMP- 3/4FP Swivel FITTING, 90 6MJ- 6MOPump ASM,TANDEM HTH FITING,TEE 12MJ- 12MO- 6FO HTH44T- Hydraulic Drive Pump Lever Assy Hydraulic Drive Pump Lever Assembly GROMMET, Leverminor #Z SPACER, Pump Lever GrommetNUT, HEX Full 1/4- 28 Left Hand ROD, Pump Actuator Hydraulic Drive Filters and Cooling HTH44T- Hydraulic Drive Filters and Cooling FITTING, 45 8 Barb X 3/8 MP CONNECTOR, Weatherpack 2 PINCLAMP, 1.1/4 Hose FITTING, 45 8BARB X 1/2 MP HTH44T- Five Blade Spider ASSY. Left Five Blade Spider Assembly Left Side PLATE, Wear SCREW, Trowel AdjustmentThrust Collar W/ Bushing Spider ASM,LEFT Side HTH44T- Five Blade Spider ASSY. Right Five Blade Spider Assembly Right Side Spider ASM, Right Side Thrust COLLAR, W/ BushingLEVER, Trowel ARM Right Side SPRING, Right Trowel HTH44T- Stabilizer Ring Assy Stabilizer Assembly WASHER, LOCK, 5/16 MED RING, STABILIZER, EXT ARM, HD Locator Decals HTH44T- Locator Decals DECAL, KEY Switch Lights DECAL, Safety CLOTHING, ISODECAL, Spring Safety DECAL, Engine Speed TOP Panel Left HTH44T- TOP Panel Left Assy PANEL, Left Back PANEL, Left FrontSeat Frame COVER, OIL Cooler TOP Panel Right HTH44T-TOP Panel Right Assy WASHER, Lock 1/4 MED BULB, Indicator LightHour Meter ROD END,10- 32 Female RH Front Panel Right HTH44T- Front Panel Right Assy SWITCH, Toggle ELEC. #9061 BOOT, Toggle SwitchSWITCH, Ignition W/KEYS Accessory Solenoid Seat and Frame HTH44T- Seat and Frame Assy PLATE, Seat HTH- 44T FRAME, SeatSeat W/ ARM Rest Frame and Fuel Tank Assy HTH44T- Frame and Fueltank Assy PANEL, Front HTH/STH Foot REST, LeftFuel CAP/ Gauge SPACER, Fuel Tank Foot Pedals Assy HTH44T- Foot Pedals Assy CABLE, Throttle ASM Foot REST, Left W/AAccelerator Pedal BASE, Speed Control Pedal HTH44T- Battery Assy Battery Cable RED Battery AssyCABLE, NEG Battery Black BRACKET, Battery BOX Spray Assy HTH44T- Spray Assy FITTING, 90 Fuel FITTING, Plastic PlasticSCREEN, Filter Dapco TANK, Retardant 5 Gallons HTH44T- Light Assy Light Assembly BRACKET, LIGHT, Right Side CONNECTOR, Wpack 2PIN ShroudBRACKET, LIGHT, Left Side BRACKET, Light HTH44T-WIRING Diagram Page Crankcase Assy Kubota V-1505 Crankcase Assy COMP. Crankcase Assembly COCK, DrainCAP, Sealing Plug OIL PAN Assy Kubota V-1505 OIL PAN Assy Bolt COMP. OIL PANPLUG, Drain FILTER, OIL Cylinder Head Assy Kubota V-1505 Cylinder Head Assy COMP. Cylinder Head Hook EngineCombustion Chamber GUIDE, Inlet Valve Gear Case Assy Kubota V-1505 Gear Case Assy COMP. CASE, Gear Assembly ROTOR, OIL PumpSEAT, Valve Ball Dipstick and Guide Assy Kubota V-1505 Dipstick and Guide Assy GAUGE, OIL Assembly GUIDE, Oilgauge Main Bearing Case Assy Kubota V-1505 Main Bearing Case Assy BOLT, Bearing Case Assembly CASE, Main BRGGASKET, BRG. Case COVER, Bearing Case Camshaft and Idle Gear Shaft Assy Kubota V-1505 Camshaft and Idle Gear Shaft Assy Tappet ASSEMBLY, CamshaftPush ROD SCREW, SET Piston and Crankshaft Assy Kubota V-1505 Piston and Crankshaft Assy BOLT, Connecting ROD Assembly ROD, ConnectingStandard PIN, Piston Flywheel Assy Kubota V-1505 Flywheel Assy PLATE, Rear END COMP. FlywheelBOLT, Flywheel Fuel Camshaft and Governor Shaft Assy Kubota V-1505 Fuel Camshaft and GOV. Shaft Assy COMP. WEIGHT, Governor HOLDER, Governor WeightSHAFT, Governor Weight CAMSHAFT, Fuel Engine Stop Lever Assy Kubota V-1505 Engine Stop Lever Assy BOLT, Adjusting Stop Solenoid Assy Kubota V-1505 Stop Solenoid Assy BOLT, HEX- SOC- HD SOLENOID, Stop Injection Pump Assy Kubota V-1505 Injection Pump Assy Assembly PUMP, Injection Assembly PIPE, FuelJOINT, EYE CLIP, Pipe Nozzle Holder and Glow Plug Assy Kubota V-1505 -NOZZLE and Glow Plug Assy SCREW, AIR Breeder Assembly HOLDER, NozzleSEAL, Heat PIPE, Injection Nozzle Holder Component Parts Assy Kubota V-1505 Nozzle Holder Component Parts Assy SPRING, Nozzle WASHER, AdjustingSPACER, Distance NUT, Nozzle Fork Lever Governor Assy Kubota V-1505 Fork Lever Governor Assy SPRING, Start Assembly LEVER, ForkSPRING, Governor LEVER, Fork Fuel Pump Mechanical Assy Kubota V-1505 Fuel Pump Mechanical Assy GASKET, Fuel Pump Assembly PUMP, Fuel Alternator and Pulley Assy Kubota V-1505 Altenator and Pully Assy Connector Assembly CouplerAssembly Terminal Assembly COUPLER, Lock Alternator Comonent Parts Assy Kubota V-1505 Altenator COMP. Parts Assy Assembly Rectifier Assembly AlernatorAssembly Regulator Alternator Component Parts Assy Starter Assy Kubota V-1505 Starter Assy Assembly Starter Starter Component Partsassy Kubota V-1505 Starter Component Parts Assy Assembly Clutch Assembly YokeAssembly Housing Assembly HOLDER, Brush OIL SWITCH/THERMOMETER and Plug Assy Kubota V-1505 OIL SWITCHT/THERMO and Plug Assy SWITCH, OIL Water Flange and Thermostat Assy Kubota V-1505 Waterflang and Thermostat Assy COMP. FLANGE, Water Assembly ThermostatPIPE, Water Return GASKET, Water Flange Water Pumpassy Kubota V-1505 Water Pump Assy IMPELLER, Water Pump Assembly PUMP, WaterFLANGE, Water Pump GASKET, Water Pump Water Pipe Assy Kubota V-1505 Water Pipe Assy Clamp PIPE, Water FAN Assy Kubota V-1505 FAN Assy COLLAR, FAN FANPULLEY, FAN Valve and Rocker ARM Assy Kubota V-1505 Valve and Rocker ARM Assy SCREW, Adjusting Assembly Rocker ARMVALVE, Inlet VALVE, Exhaust Inlet Manifold Assy Kubota V-1505 Inlet Manifold Assy PIPE, Inlet Assembly MANIFOLD, InletGASKET, IN- Manifold Exhaust Manifold Assy Kubota V-1505 Exhaust Manifold Assy GASKET, EX- Manifold MANIFOLD, Exhaust Turbo Charger Assy Kubota V-1505 Turbo Charger Assy FLANGE, Muffler Assembly Turbo Charger OIL Pipe Turbo Charger Assy Kubota V-1505 OIL Pipe Turbo Charger Assy BOLT, EYE Joint COMP. PIPE, OILPIPE, OIL CLAMP, Hose Hydraulic Pump Assy Kubota V-1505 Hydraulic Pump Assy COVER, Hydraulic Pump OIL Cooler Assy Kubota V-1505 OIL Cooler Assy Pipe COOLER, OIL Assembly COOLER, OIL Glow PLUG/LAMP and Timer Assy Kubota V-1505 Glow PLUG/LAMP and Timer Assy TIMER, Glow Lamp LAMP, Indicator Engine Stand Assy Kubota V-1505 Engine Stand Assy STAND, Engine Accessories and Service Parts Assy Kubota V-1505 Accessory and Service Parts Assy GASKET, Muffler NA Label and OPERATOR’S Manual Assy Kubota V-1505 Label Assy LABEL, Instruction Name PLATE, EngineLabel Terms and Conditions of Sale Parts Page HERE’S HOW to GET Help