HTH44T- Safety Message Alert Symbols | Multiquip guide

HTH44T— SAFETY MESSAGE ALERT SYMBOLS

Accidental Starting

ALWAYS place the ON/OFF switch in the OFF position, and remove the key.

Respiratory Hazard

ALWAYS wear approved respiratory protection.

Over Speed Conditions

Sight and Hearing hazard

NEVER tamper with the factory settings of the engine governor or settings. Personal injury and damage to the engine or equipment can result if operating in speed ranges above maximum allowable.

NOTE

This Ride-On Power Trowel, other property, or the surrounding environment could be damaged if you do not follow instructions.

ALWAYS wear approved eye and hearing protection.

Equipment Damage Messages

Other important messages are provided throughout this manual to help prevent damage to your trowel, other property, or the surrounding environment.

HTH44T • RIDE-ON POWER TROWEL — OPERATION & PARTS MANUAL — REV. #8 (03/27/12) — PAGE 9

Image 9

Multiquip manual HTH44T- Safety Message Alert Symbols, Over Speed Conditions Sight and Hearing hazard

Contents

Model HTH44T Proposition 65WARNING SILICOSIS/RESPIRATORYWARNINGS HTH44T-TABLE of Contents Ordering parts has never been easier Parts Ordering Procedures Training Checklist HTH44T-TRAINING Checklist Daily PRE-OPERATION Checklist HTH44T- Daily PRE-OPERATION Checklist HTH44T- Safety Message Alert Symbols Over Speed Conditions Sight and Hearing hazard HTH44T- Safety Message Alert Symbols HTH44T- Rules for Safe Operation HTH44T- Operation and Safety Decals HTH-44T Specifications HTH44T- Specifications HTH44T- General Information HTH44T Controls and Indicators Front HTH44T- Controls and Indicators HTH44T Controls and Indicators Rear Fuel HTH44T- Initial START-UP HTH44T- Initial START-UP Engine Throttle Control Lever High Joystick Control Forward Direction Maintenance Schedule HTH44T- Maintenance Blade Pitch Adjustment Procedure Changing a Blade Pressure Gauge Hydraulic Pump Pressure Gauge Left Steering Valve Steering Pressure Adjustment HTH44T-TROUBLESHOOTING Wiring? HTH44T- Explanation of Code in Remarks Column Unit Pivot ASSY. Left HTH44T- Pivot ASSY. Left Bushing YokeRocker Block WASHER, Lock 3/8 MED Pivot ASSY. Right HTH44T- Pivot ASSY. Right Trunnion RETAINER, ClutchSHAFT, Pivot LEFT/RIGHT Twin Pitch Assy HTH44T-TWIN Pitch ASSY. LEFT/RIGHT HTH44T-TWIN Pitch ASSY. LEFT/RIGHT COVER, Pitch Cont Housing HOUSING, Pitch CONTROL, 1-3/4KEY, Woodruff #9 WASHER, Lock 5/16 MED SLEEVE, W/U-JOINT WASHER, FLAT, 5/16 SAESET COLLAR, 1/2 Miter BOX, Pitch Control Engine Kubota HTH44T- Engine Kubota ELEMENT, AIR Cleaner HOSE, AIR CleanerWASHER, LOCK, 1/2 MED SCREW, Drive #2- 3/16 U- Drive HTH44T- Engine Flange Kubota FLANGE, Nylon Bell HOUSING, KTRHUB, Hydraulic Pump MOUNT, Right Motor Engine Fuelkubota HTH44T- Engine Fuel Kubota WASHER, LOCK, 7/16 MED FILTER, Cannister Fuel Hydraulic Steering Left HTH44T- Hydraulic Steering Left TUBE, HYD. Steering Return TUBE, HYD. Steering PressureBELLOWS, STG. Cylinder PLATE, Bellows Mounting Hydraulic Steering Right HTH44T- Hydraulic Steering Right FITTING, 45 6MJ- 6MO Hose ASM, .38 ID X 17 STR EndsHose ASM, .38 ID X 15.5 STR. Ends NUT, HEX JAM Blkhd .5625-18UNF HTH44T- Steering Valve ASSY. Left Steering Valve Assembly Left CLAMP, Boot BOOT, LeftNUT, Special PLATE, Pivot Steering Valve Assembly Right RETAINER, Strg Valve Boot BOOT, RightFITTING, 45 6MJ-6MO FITTING, TEE 6MJ-6MO-6MJ Palm Handles Left and Right HTH44T- Palm Handles Left and Right TUBE, Handle Switch HANDLE, Palm W/ SWITCH, LeftSwitch ASM Valve ASM, Steering Left Hydraulic Drive Assembly HTH44T- Hydraulic Drive Assembly FITTING, 90 IMP- 3/4FP Swivel FITTING, 90 6MJ- 6MOPump ASM,TANDEM HTH FITING,TEE 12MJ- 12MO- 6FO HTH44T- Hydraulic Drive Pump Lever Assy Hydraulic Drive Pump Lever Assembly GROMMET, Leverminor #Z SPACER, Pump Lever GrommetNUT, HEX Full 1/4- 28 Left Hand ROD, Pump Actuator Hydraulic Drive Filters and Cooling HTH44T- Hydraulic Drive Filters and Cooling FITTING, 45 8 Barb X 3/8 MP CONNECTOR, Weatherpack 2 PINCLAMP, 1.1/4 Hose FITTING, 45 8BARB X 1/2 MP HTH44T- Five Blade Spider ASSY. Left Five Blade Spider Assembly Left Side PLATE, Wear SCREW, Trowel AdjustmentThrust Collar W/ Bushing Spider ASM,LEFT Side HTH44T- Five Blade Spider ASSY. Right Five Blade Spider Assembly Right Side Spider ASM, Right Side Thrust COLLAR, W/ BushingLEVER, Trowel ARM Right Side SPRING, Right Trowel HTH44T- Stabilizer Ring Assy Stabilizer Assembly WASHER, LOCK, 5/16 MED RING, STABILIZER, EXT ARM, HD Locator Decals HTH44T- Locator Decals DECAL, KEY Switch Lights DECAL, Safety CLOTHING, ISODECAL, Spring Safety DECAL, Engine Speed TOP Panel Left HTH44T- TOP Panel Left Assy PANEL, Left Back PANEL, Left FrontSeat Frame COVER, OIL Cooler TOP Panel Right HTH44T-TOP Panel Right Assy WASHER, Lock 1/4 MED BULB, Indicator LightHour Meter ROD END,10- 32 Female RH Front Panel Right HTH44T- Front Panel Right Assy SWITCH, Toggle ELEC. #9061 BOOT, Toggle SwitchSWITCH, Ignition W/KEYS Accessory Solenoid Seat and Frame HTH44T- Seat and Frame Assy FRAME, Seat Seat W/ ARM RestPLATE, Seat HTH- 44T Frame and Fuel Tank Assy HTH44T- Frame and Fueltank Assy PANEL, Front HTH/STH Foot REST, LeftFuel CAP/ Gauge SPACER, Fuel Tank Foot Pedals Assy HTH44T- Foot Pedals Assy CABLE, Throttle ASM Foot REST, Left W/AAccelerator Pedal BASE, Speed Control Pedal HTH44T- Battery Assy Battery Cable RED Battery AssyCABLE, NEG Battery Black BRACKET, Battery BOX Spray Assy HTH44T- Spray Assy FITTING, 90 Fuel FITTING, Plastic PlasticSCREEN, Filter Dapco TANK, Retardant 5 Gallons HTH44T- Light Assy Light Assembly BRACKET, LIGHT, Right Side CONNECTOR, Wpack 2PIN ShroudBRACKET, LIGHT, Left Side BRACKET, Light HTH44T-WIRING Diagram Page Crankcase Assy Kubota V-1505 Crankcase Assy COMP. Crankcase Assembly COCK, DrainCAP, Sealing Plug OIL PAN Assy Kubota V-1505 OIL PAN Assy Bolt COMP. OIL PANPLUG, Drain FILTER, OIL Cylinder Head Assy Kubota V-1505 Cylinder Head Assy COMP. Cylinder Head Hook EngineCombustion Chamber GUIDE, Inlet Valve Gear Case Assy Kubota V-1505 Gear Case Assy COMP. CASE, Gear Assembly ROTOR, OIL PumpSEAT, Valve Ball Dipstick and Guide Assy Kubota V-1505 Dipstick and Guide Assy GAUGE, OIL Assembly GUIDE, Oilgauge Main Bearing Case Assy Kubota V-1505 Main Bearing Case Assy BOLT, Bearing Case Assembly CASE, Main BRGGASKET, BRG. Case COVER, Bearing Case Camshaft and Idle Gear Shaft Assy Kubota V-1505 Camshaft and Idle Gear Shaft Assy Tappet ASSEMBLY, CamshaftPush ROD SCREW, SET Piston and Crankshaft Assy Kubota V-1505 Piston and Crankshaft Assy BOLT, Connecting ROD Assembly ROD, ConnectingStandard PIN, Piston Flywheel Assy Kubota V-1505 Flywheel Assy COMP. Flywheel BOLT, FlywheelPLATE, Rear END Fuel Camshaft and Governor Shaft Assy Kubota V-1505 Fuel Camshaft and GOV. Shaft Assy COMP. WEIGHT, Governor HOLDER, Governor WeightSHAFT, Governor Weight CAMSHAFT, Fuel Engine Stop Lever Assy Kubota V-1505 Engine Stop Lever Assy BOLT, Adjusting Stop Solenoid Assy Kubota V-1505 Stop Solenoid Assy BOLT, HEX- SOC- HD SOLENOID, Stop Injection Pump Assy Kubota V-1505 Injection Pump Assy Assembly PUMP, Injection Assembly PIPE, FuelJOINT, EYE CLIP, Pipe Nozzle Holder and Glow Plug Assy Kubota V-1505 -NOZZLE and Glow Plug Assy SCREW, AIR Breeder Assembly HOLDER, NozzleSEAL, Heat PIPE, Injection Nozzle Holder Component Parts Assy Kubota V-1505 Nozzle Holder Component Parts Assy SPRING, Nozzle WASHER, AdjustingSPACER, Distance NUT, Nozzle Fork Lever Governor Assy Kubota V-1505 Fork Lever Governor Assy SPRING, Start Assembly LEVER, ForkSPRING, Governor LEVER, Fork Fuel Pump Mechanical Assy Kubota V-1505 Fuel Pump Mechanical Assy GASKET, Fuel Pump Assembly PUMP, Fuel Alternator and Pulley Assy Kubota V-1505 Altenator and Pully Assy Connector Assembly CouplerAssembly Terminal Assembly COUPLER, Lock Alternator Comonent Parts Assy Kubota V-1505 Altenator COMP. Parts Assy Assembly Rectifier Assembly AlernatorAssembly Regulator Alternator Component Parts Assy Starter Assy Kubota V-1505 Starter Assy Assembly Starter Starter Component Partsassy Kubota V-1505 Starter Component Parts Assy Assembly Clutch Assembly YokeAssembly Housing Assembly HOLDER, Brush OIL SWITCH/THERMOMETER and Plug Assy Kubota V-1505 OIL SWITCHT/THERMO and Plug Assy SWITCH, OIL Water Flange and Thermostat Assy Kubota V-1505 Waterflang and Thermostat Assy COMP. FLANGE, Water Assembly ThermostatPIPE, Water Return GASKET, Water Flange Water Pumpassy Kubota V-1505 Water Pump Assy IMPELLER, Water Pump Assembly PUMP, WaterFLANGE, Water Pump GASKET, Water Pump Water Pipe Assy Kubota V-1505 Water Pipe Assy Clamp PIPE, Water FAN Assy Kubota V-1505 FAN Assy FAN PULLEY, FANCOLLAR, FAN Valve and Rocker ARM Assy Kubota V-1505 Valve and Rocker ARM Assy SCREW, Adjusting Assembly Rocker ARMVALVE, Inlet VALVE, Exhaust Inlet Manifold Assy Kubota V-1505 Inlet Manifold Assy Assembly MANIFOLD, Inlet GASKET, IN- ManifoldPIPE, Inlet Exhaust Manifold Assy Kubota V-1505 Exhaust Manifold Assy GASKET, EX- Manifold MANIFOLD, Exhaust Turbo Charger Assy Kubota V-1505 Turbo Charger Assy FLANGE, Muffler Assembly Turbo Charger OIL Pipe Turbo Charger Assy Kubota V-1505 OIL Pipe Turbo Charger Assy BOLT, EYE Joint COMP. PIPE, OILPIPE, OIL CLAMP, Hose Hydraulic Pump Assy Kubota V-1505 Hydraulic Pump Assy COVER, Hydraulic Pump OIL Cooler Assy Kubota V-1505 OIL Cooler Assy Pipe COOLER, OIL Assembly COOLER, OIL Glow PLUG/LAMP and Timer Assy Kubota V-1505 Glow PLUG/LAMP and Timer Assy TIMER, Glow Lamp LAMP, Indicator Engine Stand Assy Kubota V-1505 Engine Stand Assy STAND, Engine Accessories and Service Parts Assy Kubota V-1505 Accessory and Service Parts Assy GASKET, Muffler NA Label and OPERATOR’S Manual Assy Kubota V-1505 Label Assy Name PLATE, Engine LabelLABEL, Instruction Terms and Conditions of Sale Parts Page HERE’S HOW to GET Help