Manuals / Pentair / Household Appliance / Electric Heater

Pentair MiniMax NT LN Save These Instructions, Pentair Water Pool and Spa, Inc, 4036, Rev. E

Models: MiniMax NT LN

1 36

Download 36 pages 12.01 Kb

Page 36

Image 36

4036

SAVE THESE INSTRUCTIONS

Pentair Water Pool and Spa, Inc.

1620 Hawkins Ave., Sanford, NC 27330 • (919) 566-8000

10951 W. Los Angeles Ave., Moorpark, CA 93021 • (805) 523-2400

P/N 472089

Rev. E 4-19-05

Page 36

Image 36

Pentair MiniMax NT LN Save These Instructions, Pentair Water Pool and Spa, Inc, 4036, Hawkins Ave., Sanford, NC, Rev. E

Contents

OPERATION & INSTALLATION MANUAL FOR YOUR SAFETY - READ BEFORE OPERATINGWHAT TO DO IF YOU SMELL GAS MiniMax NT LN SeriesCustomer Service Web siteTable of Contents Heater Identification Information HEATER IDENTIFICATION INFORMATION - HINH. I. N a.Heater Identification Number HINWARRANTY INFORMATION IntroductionPool and Spa Heaters IMPORTANT NOTICESCONSUMER INFORMATION AND SAFETY CODE REQUIREMENTSInstallation Instructions SPECIFICATIONSOUTDOOR INSTALLATION INDOOR INSTALLATIONBELOW POOL INSTALLATION BELOW OR ABOVE POOL INSTALLATIONPLUMBING CONNECTIONS VALVESWATER CONNECTIONS Reversible Inlet/Outlet ConnectionReversing Headers Reversing Water ConnectionsReversible Inlet/Outlet Connection, cont’d Remember The inlet and outlet markingson the header are still correct Do not plumb the heater backwardsGAS CONNECTIONS GAS LINE INSTALLATIONSSEDIMENT TRAPS GAS PIPE SIZING PIPE SIZING FOR GAS LINE CONNECTIONS1/2” 3/4”TESTING GAS PRESSURE GAS PRESSURE REQUIREMENTSINDOOR VENTING - General Requirements INDOOR INSTALLATION USA ONLY OUTDOOR SHELTER INSTALLATION CANADAbe installed directly on carpeting See page 16 for Vent AdaptorsCOMBUSTION AIR SUPPLY VENT ADAPTORSFITS ALL MODELS Vent for roof penetration installations INDOOR INSTALLATIONSVent termination for side wall installations Vent pipe extensionOUTDOOR VENT KIT ELECTRICAL CONNECTIONS 120 / 240 Volts AC, single phaseElectrical Rating 60 Hz WIRE COLOR P/N Rev. EFOR YOUR SAFETY READ BEFORE LIGHTING Operation InstructionBASIC SYSTEM OPERATION OPERATING INSTRUCTIONSSAFETY CONTROLS VACUUM AIR PRESSURE FAN SWITCHWATER PRESSURE SWITCH LOW GAS PRESSURE SWITCHSAFETY CONTROLS, cont’d HIGH LIMITSOPERATION OF IGNITION MODULE 1. HEAT MODEDIGITAL DISPLAY TEMPERATURE CONTROLLER DDTC SYSTEM INDICATOR LIGHTSREMOTE BUTTON POOL BUTTON SPA BUTTON OFF BUTTON TEMP. UPSection IV. Operation Rev. ESET UP LED INDICATORSPOWER PRESSURE SW WATER PRESSURE SWITCHTEMPERATURE SETTING REMOTE CONTROLSERVICE HEATING MODE SELECTIONTroubleshooting Instruction TROUBLESHOOTING DDTCError Code Error DescriptionTROUBLESHOOTING GENERAL SERVICE CHECKS-IGNITIONMODULEShut off gas supply and call serviceperson Heater exchanger scaledENERGY SAVING TIPS Maintenance InstructionSPRING AND FALL OPERATION WINTER OPERATIONIntroduction CHEMICAL BALANCE POOL AND SPA WATERpH Chart pH Control ChartREPLACEMENT PARTS - NT LN w/DDTC Rev. ERev. E Rev. E SAVE THESE INSTRUCTIONS Pentair Water Pool and Spa, Inc4036 1620 Hawkins Ave., Sanford, NC