Manuals / Pentair / Household Appliance / Electric Heater

Pentair MiniMax NT LN installation manual REPLACEMENT PARTS - NT LN w/DDTC, Rev. E

Models: MiniMax NT LN

1 36

Download 36 pages 12.01 Kb

Page 33

Image 33

REPLACEMENT PARTS — NT LN w/DDTC

Rev. E 4-19-05

P/N 472089

Page 33

Image 33

Pentair MiniMax NT LN installation manual REPLACEMENT PARTS - NT LN w/DDTC, Rev. E

Contents

FOR YOUR SAFETY - READ BEFORE OPERATING OPERATION & INSTALLATION MANUALWHAT TO DO IF YOU SMELL GAS MiniMax NT LN SeriesWeb site Customer ServiceTable of Contents HEATER IDENTIFICATION INFORMATION - HIN Heater Identification InformationH. I. N a.Heater Identification Number HINIntroduction WARRANTY INFORMATIONPool and Spa Heaters IMPORTANT NOTICESCODE REQUIREMENTS CONSUMER INFORMATION AND SAFETYSPECIFICATIONS Installation InstructionsOUTDOOR INSTALLATION INDOOR INSTALLATIONBELOW OR ABOVE POOL INSTALLATION BELOW POOL INSTALLATIONPLUMBING CONNECTIONS VALVESReversible Inlet/Outlet Connection WATER CONNECTIONSReversing Headers Reversing Water ConnectionsRemember The inlet and outlet markings Reversible Inlet/Outlet Connection, cont’don the header are still correct Do not plumb the heater backwardsGAS CONNECTIONS GAS LINE INSTALLATIONSSEDIMENT TRAPS PIPE SIZING FOR GAS LINE CONNECTIONS GAS PIPE SIZING1/2” 3/4”GAS PRESSURE REQUIREMENTS TESTING GAS PRESSUREINDOOR VENTING - General Requirements OUTDOOR SHELTER INSTALLATION CANADA INDOOR INSTALLATION USA ONLYbe installed directly on carpeting See page 16 for Vent AdaptorsCOMBUSTION AIR SUPPLY VENT ADAPTORSFITS ALL MODELS INDOOR INSTALLATIONS Vent for roof penetration installationsVent termination for side wall installations Vent pipe extensionOUTDOOR VENT KIT ELECTRICAL CONNECTIONS 120 / 240 Volts AC, single phaseElectrical Rating 60 Hz P/N Rev. E WIRE COLOROperation Instruction FOR YOUR SAFETY READ BEFORE LIGHTINGBASIC SYSTEM OPERATION OPERATING INSTRUCTIONSVACUUM AIR PRESSURE FAN SWITCH SAFETY CONTROLSWATER PRESSURE SWITCH LOW GAS PRESSURE SWITCHHIGH LIMITS SAFETY CONTROLS, cont’dOPERATION OF IGNITION MODULE 1. HEAT MODESYSTEM INDICATOR LIGHTS DIGITAL DISPLAY TEMPERATURE CONTROLLER DDTCREMOTE BUTTON POOL BUTTON SPA BUTTON OFF BUTTON TEMP. UPRev. E Section IV. OperationLED INDICATORS SET UPPOWER PRESSURE SW WATER PRESSURE SWITCHREMOTE CONTROL TEMPERATURE SETTINGSERVICE HEATING MODE SELECTIONTROUBLESHOOTING DDTC Troubleshooting InstructionError Code Error DescriptionSERVICE CHECKS-IGNITIONMODULE TROUBLESHOOTING GENERALShut off gas supply and call serviceperson Heater exchanger scaledMaintenance Instruction ENERGY SAVING TIPSSPRING AND FALL OPERATION WINTER OPERATIONIntroduction POOL AND SPA WATER CHEMICAL BALANCEpH Chart pH Control ChartRev. E REPLACEMENT PARTS - NT LN w/DDTCRev. E Rev. E Pentair Water Pool and Spa, Inc SAVE THESE INSTRUCTIONS4036 1620 Hawkins Ave., Sanford, NC