Manuals / Raypak / Lawn and Garden / Swimming Pool Heater

Raypak P-926, P-1826, P-2100, P-4001 Models 2100 thru, Blended Water Temperature, Thermometer

Models: P926, P1826, P2100, P4001 P-926, P-1826, P-2100, P-4001 1287-1758, 2100-4001

1 38

Download 38 pages 3.29 Kb

Page 13

Models 2100 thru 4001

PIPING CONFIGURATIONS FOR RAYTHERM COMMERCIAL POOL HEATERS

Fig # 9268

Fig # 9269

Models 2100 thru 4001

TI	BLENDED WATER TEMPERATURE
	(THERMOMETER AT HEATER INLET)
To	HEATER OUTLET TEMPERATURE
	THERMOMETER

Tc HEATER THERMOSTAT

RECOMMENDED FIELD INSTALLED

ISOLATION VALVES FOR SERVICE

13

Image 13

Raypak P-926, P-1826, P-2100, P-4001 manual Models 2100 thru, Blended Water Temperature, Thermometer At Heater Inlet, Fig #

Contents

COMMMERCIAL SWIMMING POOL HEATER Models INSTALLATION AND OPERATING INSTRUCTIONS RAYTHERMTMP-926 to P-1826 and P-2100 to P-4001 3 SECTION 1 RECEIVING EQUIPMENT 3 SECTION 2 GENERAL SPECIFICATIONS Contents3 SECTION 3 INSTALLATION INSTRUCTIONS 25 SECTION 5 TROUBLE SHOOTINGSECTION 3 / INSTALLATION INSTRUCTIONS SECTION 2 / GENERAL SPECIFICATIONSBASE INSTALLATION SECTION 1 / RECEIVING EQUIPMENTCLEARANCES Z223.1/NFPA VENTINGCONNECTIONSGAS SUPPLY CONNECTIONS WATERCONNECTIONS CONTROLS FLOW RATES/WATER CONNECTIONS MODELS 1287/1336 - 1758/1826MODEL CONNECTIONSIZE1. Remove the poolstat control cover by removing the two cover MOUNTING WELL INTO SYSTEM RETURN LOOP PIPE - FRONT-MOUNTED LOOP Note Consult factory if target temperatures cannot be achieved To adjust the temperatureHEATER OUTLET TEMPERATURE BLENDED WATER TEMPERATURETc HEATER THERMOSTAT RECOMMENDED FIELD INSTALLED ISOLATION VALVES FOR SERVICEEXTERNAL AUXILIARY BYPASS VALVE Where Required 926-1223 Models only PRESSURE SWITCH ELECTRICAL WIRINGGAS MANIFOLD WIRING DIAGRAM MODELS 926 WIRING DIAGRAM MODELS1287-1826 WIRING DIAGRAM MODELS WIRING DIAGRAM MODELS GENERAL LOCATION OF CONTROLS SECTION 4/ SERVICING INSTRUCTIONSSTART-UPPROCEDURES INSPECTIONPROCEDURES RAYPAK TUBE CLEANING KIT SERVICING PROCEDURESBURNER DRAWER REMOVAL CONTROL WELL REPLACEMENT WINTERIZATION MAINTENANCEANDCAREMECHANICAL FOR QUALIFIED SERVICE PERSONNEL ONLY SECTION 5 / TROUBLESHOOTING GUIDEIMPORTANT NOTICE This does not take into account heat POWER TO MODULE 24 V NOMINAL YES SPARK ACROSS IGNITER/SENSOR GAP YES Intermittent Pilot SystemSYSTEM SHUTS OFF? YES TROUBLESHOOTING ENDS Check continuity of ignition cable and ground wire Clean flame rodRaypak, Inc 2151 Eastman Avenue Oxnard, CA SECTION 6 / REPLACEMENT PARTS LISTPage Page Page MODELS 2100, 2500, 3001, 3500 Page Page LIMITED WARRANTY RAYTHERM TYPE P SIZES Litho in U.S.A