Manuals
/
Raypak
/
Lawn and Garden
/
Swimming Pool Heater
Raypak
1287-1758, 2100-4001, P-926, P-1826, P-2100, P-4001, P926, P1826, P2100, P4001 manual
Models:
P926, P1826, P2100, P4001
P-926, P-1826, P-2100, P-4001
1287-1758, 2100-4001
1
33
38
38
Download
38 pages
3.29 Kb
30
31
32
33
34
35
36
37
<
>
Troubleshooting
Specification
Install
Parts list
WIRING DIAGRAM MODELS 926
Control Well Replacement
Warranty
Maintenance
Electrical Wiring
Adjust pilot flame If problem persists, replace module
Page 33
Image 33
33
Page 32
Page 34
Page 33
Image 33
Page 32
Page 34
Contents
INSTALLATION AND OPERATING INSTRUCTIONS RAYTHERMTM
COMMMERCIAL SWIMMING POOL HEATER Models
P-926 to P-1826 and P-2100 to P-4001
3 SECTION 1 RECEIVING EQUIPMENT 3 SECTION 2 GENERAL SPECIFICATIONS
Contents
3 SECTION 3 INSTALLATION INSTRUCTIONS
25 SECTION 5 TROUBLE SHOOTING
SECTION 3 / INSTALLATION INSTRUCTIONS
SECTION 2 / GENERAL SPECIFICATIONS
BASE INSTALLATION
SECTION 1 / RECEIVING EQUIPMENT
CLEARANCES
Z223.1/NFPA
VENTINGCONNECTIONS
GAS SUPPLY CONNECTIONS
WATERCONNECTIONS
CONTROLS
FLOW RATES/WATER CONNECTIONS
MODELS 1287/1336 - 1758/1826
MODEL
CONNECTIONSIZE
1. Remove the poolstat control cover by removing the two cover
MOUNTING WELL INTO SYSTEM RETURN LOOP PIPE - FRONT-MOUNTED LOOP
Note Consult factory if target temperatures cannot be achieved
To adjust the temperature
HEATER OUTLET TEMPERATURE
BLENDED WATER TEMPERATURE
Tc HEATER THERMOSTAT RECOMMENDED FIELD INSTALLED
ISOLATION VALVES FOR SERVICE
EXTERNAL AUXILIARY BYPASS VALVE Where Required 926-1223 Models only
ELECTRICAL WIRING
PRESSURE SWITCH
GAS MANIFOLD
WIRING DIAGRAM MODELS 926
WIRING DIAGRAM MODELS1287-1826
WIRING DIAGRAM MODELS
WIRING DIAGRAM MODELS
GENERAL LOCATION OF CONTROLS
SECTION 4/ SERVICING INSTRUCTIONS
START-UPPROCEDURES
INSPECTIONPROCEDURES
RAYPAK TUBE CLEANING KIT
SERVICING PROCEDURES
BURNER DRAWER REMOVAL
CONTROL WELL REPLACEMENT
WINTERIZATION
MAINTENANCEANDCARE
SECTION 5 / TROUBLESHOOTING GUIDE
MECHANICAL FOR QUALIFIED SERVICE PERSONNEL ONLY
IMPORTANT NOTICE
This does not take into account heat
POWER TO MODULE 24 V NOMINAL YES SPARK ACROSS IGNITER/SENSOR GAP YES
Intermittent Pilot System
SYSTEM SHUTS OFF? YES TROUBLESHOOTING ENDS
Check continuity of ignition cable and ground wire Clean flame rod
Raypak, Inc 2151 Eastman Avenue Oxnard, CA
SECTION 6 / REPLACEMENT PARTS LIST
Page
Page
Page
MODELS 2100, 2500, 3001, 3500
Page
Page
LIMITED WARRANTY RAYTHERM TYPE P SIZES
Litho in U.S.A
