Sharp FO-2970M operation manual A R P

S H A R P

Date Revised :

Date Issued : July. 16. 1999

MATERIAL SAFETY DATA SHEET (1/2)

MSDS No. P-00102

Section 1. Product Identification

Product: FO-2970/FO29ND,FO-29DC,FO-29DCCN (Black Toner)

Section 2. Supplier’s Name and Address

Sharp Corporation

22-22 Nagaike-cho, Abeno-ku, Osaka, Japan

Local suppliers are listed below. Please contact the nearest supplier for additional information.

(Country)	(Name and Telephone Number)
U.S.A	Sharp Document Network System of America
	Telephone number for information	: 1-800-237-4277
	Emergency telephone number	: 1-800-255-3924
Canada	Sharp Electronics of Canada Ltd.
	Telephone number for information	: 905-890-2100
	Emergency telephone number	: 1-800-255-3924
United	Sharp Electronics (U.K.) Ltd.
Kingdom	Telephone number for information	: 01923-474013

Section 3.	Ingredients
Ingredients		CAS No.	Proportion		OSHA PEL	ACGIH TLV	Other Limits
Carbon black		1333-86-4	>	5%	3.5m /m3	3.5m /m3	None
Styrene-Acrylate copolymer		25036-16-2	> 90%		Not listed	Not listed	None
Iron oxide		1317-61-9	<	2%	Not listed	Not listed	None
Silica		68909-20-6	<	2%	0.8m /m3	10m /m3	None
Section 4.	Hazardous Identification (Emergency Overview)

Toner is a fine, black powder possessing no immediate hazard. There are no anticipated carcinogenic effects from exposure based on animal tests performed using toner. When used as intended according to instructions, studies do not indicate any symptoms of fibrosis will occur.

Section 5. Health Hazard Data

Route(s) of Entry	: Inhalation?	Skin?		Ingestion?
	Yes	No	Possible but very unusual.
Health Hazards	: Acute oral toxicity—LD50 of this toner is over 2,000m			/k .
	Mutagenicity—The result of Ames test is negative.
Carcinogenicity	: In 1996 the IARC reevaluated carbon black as a Group 2B carcinogen (possi-

ble human carcinogen). This classification is given to chemicals for which there is inadequate human evidence, but sufficient animal evidence on which to base an opinion of carcinogenic- ity. The classification is based upon the development of lung tumors in rats receiving chronic inhalation exposures to free carbon black at levels that induce particle overload of the lung.

Studies performed in animal models other than rats did not show any association between carbon black and lung tumors. Moreover, a two-year cancer bioassay using a typical toner preparation containing carbon black demonstrated no association between toner exposure and tumor development in rats.

Chronic Effect	: In a study in rats of chronic inhalation exposure to a typical toner, a mild to
moderate degree of lung fibrosis was observed in 92% of the rats in the high concentration
(16m	/m3) exposure group, and a minimal to mild degree of fibrosis was noted in 22% of the
animals in the middle (4m		/m3) exposure group, but no pulmonary change was reported in
the lowest (1m /m3) exposure group, the most relevant level to potential human exposures.
Signs and Symptoms of Exposure		: Minimal irritation to respiratory tract may occur as with exposure
to any non-toxic dust.

Medical Conditions Generally Aggravated by Exposure : None

138