Manuals
/
Snapper
/
Lawn and Garden
/
Lawn Mower
Snapper
ZM2200K, ZM2200KU, ZM2500K, ZM2500KH, MZM2200KH, ZM5200M, ZM6100M Primary Maintenance
Models:
ZM2200K, ZM2200KU, ZM2500K, ZM2500KH, MZM2200KH, ZM5200M, ZM6100M
ZM2500K, ZM2200K, ZM2200KU, ZM2500KH, MZM2200KH ZM522M, ZM6100M
1
27
32
32
Download
32 pages
37.3 Kb
24
25
26
27
28
29
30
31
<
>
Troubleshooting
Battery Condition Chart
Mower Drive Belt Replacement
Warranty
Maintenance
NOTE The engine does not have to be running to adjust cutting height
BATTERY 4.7.1. BATTERY REMOVAL
a. Lower deck to lowest setting b. Remove foot rest. See Figure
Safety
Power Transfer Shaft
Page 27
Image 27
PRIMARY MAINTENANCE
27
Page 26
Page 28
Page 27
Image 27
Page 26
Page 28
Contents
MOWER UNIT MODELS
Safety Instructions & Operator’s Manual for
POWER UNIT MODELS
MID MOUNT Z-RIDER ZERO TURNING HYDRO DRIVE SERIES
IMPORTANT SAFETY INSTRUCTIONS
2. Start engine from operators seat, if possible. Make sure blades are OFF and parking brake is set
IMPORTANT SAFETY INSTRUCTIONS
TABLE OF CONTENTS
Section 1 - FAMILIARIZATION
1.1 INTRODUCTION
1.2 NOMENCLATURE
2.1 PRE-START CHECK LIST
Section 2 - OPERATING INSTRUCTIONS
2.2.2. STOPPING ENGINE
Section 2 - OPERATING INSTRUCTIONS
2.2 STARTING & STOPPING - ENGINE, BLADES, PARKING BRAKE
2.2.1. STARTING ENGINE
POSITION
Section 2 - OPERATING INSTRUCTIONS
2.2.5. PARKING BRAKE
JOYSTICK IN NEUTRAL POSITION PARKING BRAKE LEVER IN ENGAGED “ON”
Section 2 - OPERATING INSTRUCTIONS
NOTE The engine does not have to be running to adjust cutting height
3.2.2. CHECK MOWER BLADE
Section 3 - MAINTENANCE
3.2 SERVICE - AFTER FIRST 5 HOURS
3.1 INTRODUCTION
a. Lower deck to lowest setting b. Remove foot rest. See Figure
Section 3 - MAINTENANCE
2. Transaxle
Section 3 - MAINTENANCE
3. Power Transfer Shaft
3.3.3. RIDING MOWER - LUBRICATION 1. Front Wheel Bearings
3.6 DECK REMOVAL
Section 3 - MAINTENANCE
TRANSFER SHAFT LOCK COLLAR TAKE OFF SHAFT
Section 3 - MAINTENANCE
REAR LIFT ARM REAR LINK SHOULDERPLATE BOLT WASHER NUT THREADED END
FRONT AXLE COTTER PIN WASHERS PULL BAR CLEVIS PIN
DANGER
Section 4 - ADJUSTMENTS & REPAIR
FIGURE 4.2A
Section 4 - ADJUSTMENTS & REPAIR
4.2.1. MOWER DECK ADJUSTMENT LEVELNESS Continued
FRONT to REAR LEVEL
DO NOT USE ON MOWER REPLACE WITH NEW BLADE
Section 4 - ADJUSTMENTS & REPAIR
PARKING BRAKE LEVER PARKING BRAKE ROD
NEW BLADE WEAR LIMIT NOTCH STARTS DANGEROUS CONDITION
4.5.2. BLADE SHARPENING
Section 4 - ADJUSTMENTS & REPAIR
4.6 MOWER DRIVE BELT REPLACEMENT
4.6.2. BELT REPLACEMENT
4.7 BATTERY 4.7.1. BATTERY REMOVAL
Section 4 - ADJUSTMENTS & REPAIR
Battery Condition Chart
Section 4 - ADJUSTMENTS & REPAIR
Engine
TROUBLESHOOTING
Engine Loses Power
Starter Will Not Crank
Loss Of Traction
TROUBLESHOOTING
Battery Will Not Charge
Tractor Will Not Move
52” MOWER DECK
SERVICE SCHEDULE
MAINTENANCE PARTS
MAINTENANCE/REPLACEMENT PARTS
2 YEAR LIMITED WARRANTY
PRIMARY MAINTENANCE
PRIMARY MAINTENANCE
PRIMARY MAINTENANCE
PRIMARY MAINTENANCE
Page
Page
Page
MID MOUNT Z-RIDER ZERO TURNING HYDRO DRIVE SERIES
Safety Instructions & Operator’s Manual for
