Manuals
/
Snapper
/
Lawn and Garden
/
Lawn Mower
Snapper
ZM2500K, ZM2200K, ZM2200KU, ZM2500KH, MZM2200KH ZM522M, ZM6100M Primary Maintenance
Models:
ZM2200K, ZM2200KU, ZM2500K, ZM2500KH, MZM2200KH, ZM5200M, ZM6100M
ZM2500K, ZM2200K, ZM2200KU, ZM2500KH, MZM2200KH ZM522M, ZM6100M
1
28
32
32
Download
32 pages
37.3 Kb
25
26
27
28
29
30
31
32
<
>
Troubleshooting
Belt Replacement
Warranty
Maintenance
Battery Condition Chart
Safety
Power Unit Models
Service Schedule
Page 28
Image 28
PRIMARY MAINTENANCE
28
Page 27
Page 29
Page 28
Image 28
Page 27
Page 29
Contents
Safety Instructions & Operator’s Manual for
POWER UNIT MODELS
MID MOUNT Z-RIDER ZERO TURNING HYDRO DRIVE SERIES
MOWER UNIT MODELS
IMPORTANT SAFETY INSTRUCTIONS
IMPORTANT SAFETY INSTRUCTIONS
2. Start engine from operators seat, if possible. Make sure blades are OFF and parking brake is set
TABLE OF CONTENTS
1.1 INTRODUCTION
Section 1 - FAMILIARIZATION
1.2 NOMENCLATURE
Section 2 - OPERATING INSTRUCTIONS
2.1 PRE-START CHECK LIST
Section 2 - OPERATING INSTRUCTIONS
2.2 STARTING & STOPPING - ENGINE, BLADES, PARKING BRAKE
2.2.1. STARTING ENGINE
2.2.2. STOPPING ENGINE
Section 2 - OPERATING INSTRUCTIONS
2.2.5. PARKING BRAKE
JOYSTICK IN NEUTRAL POSITION PARKING BRAKE LEVER IN ENGAGED “ON”
POSITION
NOTE The engine does not have to be running to adjust cutting height
Section 2 - OPERATING INSTRUCTIONS
Section 3 - MAINTENANCE
3.2 SERVICE - AFTER FIRST 5 HOURS
3.1 INTRODUCTION
3.2.2. CHECK MOWER BLADE
Section 3 - MAINTENANCE
a. Lower deck to lowest setting b. Remove foot rest. See Figure
Section 3 - MAINTENANCE
3. Power Transfer Shaft
3.3.3. RIDING MOWER - LUBRICATION 1. Front Wheel Bearings
2. Transaxle
Section 3 - MAINTENANCE
3.6 DECK REMOVAL
Section 3 - MAINTENANCE
REAR LIFT ARM REAR LINK SHOULDERPLATE BOLT WASHER NUT THREADED END
FRONT AXLE COTTER PIN WASHERS PULL BAR CLEVIS PIN
TRANSFER SHAFT LOCK COLLAR TAKE OFF SHAFT
Section 4 - ADJUSTMENTS & REPAIR
DANGER
Section 4 - ADJUSTMENTS & REPAIR
4.2.1. MOWER DECK ADJUSTMENT LEVELNESS Continued
FRONT to REAR LEVEL
FIGURE 4.2A
Section 4 - ADJUSTMENTS & REPAIR
PARKING BRAKE LEVER PARKING BRAKE ROD
NEW BLADE WEAR LIMIT NOTCH STARTS DANGEROUS CONDITION
DO NOT USE ON MOWER REPLACE WITH NEW BLADE
Section 4 - ADJUSTMENTS & REPAIR
4.6 MOWER DRIVE BELT REPLACEMENT
4.6.2. BELT REPLACEMENT
4.5.2. BLADE SHARPENING
Section 4 - ADJUSTMENTS & REPAIR
4.7 BATTERY 4.7.1. BATTERY REMOVAL
Section 4 - ADJUSTMENTS & REPAIR
Battery Condition Chart
TROUBLESHOOTING
Engine Loses Power
Starter Will Not Crank
Engine
TROUBLESHOOTING
Battery Will Not Charge
Tractor Will Not Move
Loss Of Traction
SERVICE SCHEDULE
MAINTENANCE PARTS
MAINTENANCE/REPLACEMENT PARTS
52” MOWER DECK
2 YEAR LIMITED WARRANTY
PRIMARY MAINTENANCE
PRIMARY MAINTENANCE
PRIMARY MAINTENANCE
PRIMARY MAINTENANCE
Page
Page
Page
Safety Instructions & Operator’s Manual for
MID MOUNT Z-RIDER ZERO TURNING HYDRO DRIVE SERIES
