Vermont Casting 1990 installation instructions

Homeowner’s

Installation and

Operating Manual

For use in the

United States and Canada

Do Not Discard This Manual: Retain for Future Use

2000966 2/07 Rev. 19

The Intrepid II

Woodburning Stove

Model 1990

SAFETY NOTICE: IF THIS APPLIANCE IS NOT PROPERLY INSTALLED, OPERATED AND MAIN-

TAINED, A HOUSE FIRE MAY RESULT.

TO REDUCE THE RISK OF FIRE, FOLLOW THE INSTALLATION INSTRUCTIONS. FAILURE TO

FOLLOW INSTRUCTIONS MAY RESULT IN PROPERTY DAMAGE, BODILY INJURY OR EVEN

DEATH. CONTACT LOCAL BUILDING OFFICIALS ABOUT RESTRICTIONS AND INSTALLATION

INSPECTION REQUIREMENTS IN YOUR AREA.

0966

Intrepid Cover

11/00

Contents

Main The Intrepid II Woodburning Stove Welcome All of us at CFM Corporation Table of Contents Specications Intrepid II, Model 1990 0966 Intrepid II specifications 11/00 Installation Outside Air What Kind of Chimney to Use Masonry Chimneys Prefabricated Chimneys Chimney Size Chimney Connector Guidelines Double-wall Chimney Connector Single-wall Chimney Connector Securing the Single-wall Connector to a Prefabricated Chimney Securing the Single-wall Connector to a Masonry Chimney * * Fireplace Chimney Installations - Through a Fireplace Wall Pass-Throughs ST493a Brick pass thru 11/00 Floor Protection Floor Protection for Fireplace Installations ST247 Rear exit floor dgrm 12/14/99 djt Keep the Stove and Connector a Safe Distance from Surrounding Materials Reducing Clearances Stove Heat Shields Wall Shields ST248 wall shield construction 12/14/99 djt Chimney Connector Clearance Reductions Fireplace and Mantel Trim Shields Alcove Installations Construction Requirements ST503 Alcove side view 11/10/00 djt Fig. 17 Alcove side section. Fig. 18 Cutaway perspective of alcove installation. ST506 Alcove front view 11/00 Intrepid II Clearance Chart Unprotected Surfaces Protected Surfaces Stove Clearance Front Clearance to Combustibles Chimney Connector Clearance Intrepid II Clearance Diagrams Protected Surfaces Unprotected Surfaces Wall Shield Requirements for Some Common Intrepid II Installations Distance from the Center of the Flue Collar to the Wall in Top-Exit Installations * * Parallel Installations Corner Parallel Installations Corner Intrepid II: WITH Stove and Chimney Connector Heat Shields Assembly ST513 Remove leg bolts 11/00 Install the Bottom Heat Shield Storing the Handle Reversing the Flue Collar Operation Your Intrepid IIs Controls and What They Do ST517 Intrepid II Thermostat positions 11/17/00 djt A Damper Directs Air Flow Within the Stove Andirons ST520 Intrepid andirons 11/20/00 djt Two Ways to Add Fuel Glass Door Panels ST522 Intrepid close doors 11/00 Burn Only High-Quality Wood ST523 Intrepid temp readings 11/00 Use the Air Control Settings that Work Best for You How to Build a Wood Fire and Keep it Going High-Efciency Wood Burning with Catalytic Combustion Conditioning Your Stove Starting and Maintaining a Wood Fire ST263 starting a fire 12/99 Refuel While the Embers are Still Hot ST264 good fire 12/99 ST264a add wood fire 11/00 Ash Disposal Draft Management Masonry Chimney Steel Chimney Indoor/Outdoor location Flue sizing Creosote Fuel Back-pufng Draft Testing Negative Pressure Maintenance Care of the Cast Iron Surface Care of Porcelain Enamel Finish Cleaning the Glass ST532 damper adj 11/00 How to Adjust the Door Latch ST524 Intrepid II primary air shutter 11/22/00 djt ST531 Door Pawl 11/00 Tighten the Damper Handle as Needed The Catalytic Combustion System Inspection and Cleaning When to Suspect a Combustion System Problem Replace the Stove Gaskets as Needed ST533 remove catalyst 11/00 Replace Refractory Package Adjust the Door if Necessary Permanent Gaskets The Chimney System Creosote Annual Maintenance Page Appendix: Catalytic Combustor Blockage Masking and Poisoning Flame Impingement Mechanical Damage Intrepid II Woodburning Stove Model 1990 Intrepid II Woodburning Stove Model 1990 (continued) Intrepid II Woodburning Stove Model 1990 (continued) Page Page Warranty Limited 3 Year Warranty Limited 1 Year Warranty Limited Catalyst Warranty Exclusions & Limitations