Weed Eater 545186748 instruction manual Limited Warranty, Troubleshooting Table Cause Remedy

TROUBLESHOOTING TABLE

WARNING: Always stop unit and disconnect spark plug before performing all of the recommended remedies below except remedies that require operation of the unit.

TROUBLE	CAUSE		REMEDY
Engine will not	1. Engine flooded.		1. See “Starting a Flooded Engine” in
start.				Operation Section.
	2. Fuel tank empty.		2. Fill tank with correct fuel mixture.
	3. Spark plug not firing.		3. Install new spark plug.
	4. Fuel not reaching		4. Check for dirty fuel filter; replace.
		carburetor.		Check for kinked or split fuel line;
				repair or replace.
	5. Carburetor requires		5. Contact an authorized service dealer.
		adjustment.
Engine will	1.	Carburetor requires	1.	See “Carburetor Adjustment” in
not idle		adjustment.		Service and Adjustments Section.
properly.	2.	Crankshaft seals worn.	2.	Contact an authorized service dealer.
	3.	Compression low.	3.	Contact an authorized service dealer.
Engine will not	1.	Air filter dirty.	1.	Clean or replace air filter.
accelerate,	2. Spark plug fouled.		2.	Clean or replace plug
lacks power,				and regap.
or dies under	3.	Carburetor requires	3.	Contact an authorized service dealer.
a load.	4.	adjustment.	4.	Contact an authorized service dealer.
		Carbon build-up on
		muffler outlet screen.
	5.	Compression low.	5.	Contact an authorized service dealer.
Engine	1.	Choke partially on.	1.	Adjust choke.
smokes	2.	Fuel mixture incorrect.	2.	Empty fuel tank and refill with
excessively.				correct fuel mixture.
	3.	Air filter dirty.	3.	Clean or replace air filter.
	4.	Carburetor requires	4.	Contact an authorized service dealer.
		adjustment.
Engine runs	1. Fuel mixture incorrect.		1.	See “Fueling Engine” in Operation
hot.				section.
	2. Spark plug incorrect.		2.	Replace with correct spark plug.
	3. Carburetor requires		3.	Contact an authorized service dealer.
		adjustment.	4.	Contact an authorized service dealer.
	4. Carbon build-up on
		muffler outlet screen.

LIMITED WARRANTY

WEED EATER, a division of Husqvarna Out- door Products Inc., warrants to the original con- sumer purchaser that each new WEED EATER brand gasoline tool or attachment is free from defects in material and workmanship and agrees to repair or replace under this warranty any defective gasoline product or attachment as follows from the original date of purchase.

2 YEARS - Parts and Labor, when used for household purposes.

90 DAYS - Parts and Labor, when used for commercial, professional, or income producing purposes.

30 DAYS - Parts and Labor, if used for rental purposes.

This warranty is not transferable and does not cover damage or liability caused by improper handling, improper maintenance or alteration, or the use of accessories and/or attachments not

specifically recommended by WEED EATER for this tool. This warranty does not cover tune-- up, spark plugs, filters, starter ropes, cutting line, or rotating head parts that will wear and re- quire replacement with reasonable use during the warranty period. This warranty does not cover pre--delivery setup or normal adjustments explained in the instruction manual. This war- ranty does not cover transportation costs.

In the event you have a claim under this warran- ty, you must return the product to an authorized service dealer.

Should you have any unanswered questions concerning this warranty, please contact: WEED EATER, a division of

Husqvarna Outdoor Products Inc.

1030 Stevens Creek Road Augusta, GA 30907 1--800--554--6723

9