Husqvarna AP3000 owner manual Table of Contents

Page 3

•Never refuel the machine indoors.

•Never store the machine or fuel container where there is an open fl ame, spark or pilot light such as a water heater or on other appliances.

•Never fi ll containers inside a vehicle, on a truck or trailer bed with a plastic liner. Always place containers on the ground away from your vehicle before fi lling.

•Remove gas-powered equipment from the truck or trailer and refuel it on the ground. If this is not possible, then refuel such equipment with a portable container, rather than from a gasoline dispenser nozzle.

•Keep the nozzle in contact with the rim of the fuel tank or container opening at all times until fueling is complete. Do not use a nozzle lock-open device.

•If fuel is spilled on clothing, change clothing immedi- ately.

•Never overfi ll fuel tank. Replace gas cap and tighten securely.

V. GENERAL SERVICE

•Never run a machine inside a closed area.

•Never make adjustments or repairs with the engine (motor) running. Disconnect spark plug wire, and keep

wire away from plug to prevent accidental starting.

•Keep nuts and bolts, especially blade attachement bolts, tight and keep equipment in good condition.

•Never tamper with safety devices. Check their proper operation regularly.

•Keep machine free of grass, leaves, or other debris build-up. Clean oil or fuel spillage. Allow machine to cool before storing.

•Stop and inspect the equipment if you strike an object. Repair, if necessary, before restarting.

•Never attempt to make wheel height adjustments while the engine (motor) is running.

•Grass catcher components are subject to wear, dam- age, and deterioration, which could expose moving parts or allow objects to be thrown. Frequently check components and replace with manufacturer’s recom- mended parts, when necessary.

•Mower blade is sharp and can cut. Wrap the blade or wear gloves, and use extra caution when servicing it.

•Do not change the engine governor setting or overspeed the engine.

•Maintain or replace safety and instruction labels, as necessary.

WARNING: This lawn mower is equipped with an internal combustion engine and should not be used on or near any unimproved forest-covered, brush-covered or grass-covered land unless the engine’s exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any). If a spark arrester is used, it should be maintained in effective working order by the operator.

A spark arrester for the muffl er is available through your nearest Husqvarna service center.

CONGRATULATIONS on your purchase of a new lawn mower. It has been designed, engineered and manufactured to give you the best possible dependability and performance.

Should you experience any problem you cannot easily remedy, please contact your nearest Husqvarna service center/department. We have competent, well-trained technicians and the proper tools to service or repair this lawn mower.

Please read and retain this manual. The instructions will enable you to assemble and maintain your lawn mower properly. Always observe the “SAFETY RULES”.

SERIAL

NUMBER: _________________________________

DATE OF PURCHASE: _______________________

THE MODELAND SERIAL NUMBERS WILL BE FOUND ON ADECALATTACHED TO THE REAR OF THE LAWN MOWER HOUSING.

YOU SHOULD RECORD BOTH SERIAL NUMBER AND DATE OF PURCHASE AND KEEP IN A SAFE PLACE FOR FUTURE REFERENCE.

PRODUCT SPECIFICATIONS

Gasoline Capacity

1,5 Litres

and Type:

(Unleaded Regular Only)

 

 

Oil Type (API SG–SL):

SAE 30 (above 0°C/32°F);

 

SAE 5W-30 (below 0°C/32°F)

 

 

Oil Capacity:

0,58 Litres

 

 

Spark Plug (Gap: 0,76mm):

Champion RJ19LM

 

 

Blade Bolt Torque:

35-40 ft. lbs. (47-54 N-m)

 

 

CUSTOMER RESPONSIBILITIES

•Read and observe the safety rules.

•Follow a regular schedule in maintaining, caring for and using your lawn mower.

•Follow the instructions under “Maintenance” and “Stor- age” sections of this owner’s manual.

TABLE OF CONTENTS

SAFETY RULES

2-3

 

PRODUCT SPECIFICATIONS

3

 

CUSTOMER RESPONSIBILITIES

3

 

ASSEMBLY

4

 

OPERATION

5-9

 

MAINTENANCE SCHEDULE

10

3

MAINTENANCE

10-12

SERVICE AND ADJUSTMENTS

13-14

STORAGE

14-15

TROUBLESHOOTING

16

REPAIR PARTS

33-37

WARRANTY

38

Page 2 Page 4
Image 3
Page 2 Page 4
Contents 67521HV III. Children Safe Operation Practices for Walk-Behind MowersII. Slope Operation General OperationTable of Contents To Remove Mower from Carton AssemblyHOW to SET UP Your Mower To Install AttachmentsMeets Cpsc Safety Requirements OperationKnow Your Lawn Mower HOW to USE Your Lawn Mower Engine SpeedEngine Zone Control When Converting Your Lawn Mower To Convert Mower See FigsSimple Steps to Remember ADD Gasoline See Fig Before Starting EngineTo Empty Grass Catcher See Figs ADD OIL See FigMulching Mowing Tips Mowing TipsTo Stop Engine To Start EngineBefore Each USE MaintenanceLubrication Chart General RecommendationsLawn Mower Muffler CleaningClean Under Drive Cover EngineTo Remove Drive Belt See Figs Service and AdjustmentsTo Adjust Cutting Height Rear DeflectorHandle See Figs To Adjust Handle See FigStorage CarburetorCylinder OtherFuel System Engine OILProblem Cause Correction Troubleshooting PointsIV. Manejo Seguro DE Gasolina II. Operacion Sobre LAS CuestasOperacion III. NiñosEspecificaciones DEL Producto Tabla DE MateriasResponsabilidades DEL Cliente ServicioPara Desdoblar EL Mango Vea la Figs y MontajePara Remover LA Segadora DE LA Caja DE Cartón Como Preparar SU SegadoraOperación Familiarícese CON SU SegadoraCumple CON LOS Requisitos DE Seguridad DE LA Cpsc Como Usar SU Segadora Velocidad DEL MotorControl DE Zona DEL Motor Pasos Simples DE Recordar Cuando Convierta SU Segadora Importante Antes DE Hacer Arrancar EL MotorPara Vaciar EL Recogedor DE Césped Vea la Figs y Agregue Aceite Vea FigPara Hacer Arrancar EL Motor Consejos Para SegarAgregue Gasolina Vea Fig Para Parar EL MotorAntes DE Cada USO MantenimientoRecomendaciones Generales Tabla DE LubricaciónCuidado DE LA Cuchilla SegadoraLlantas Ruedas DE ImpulsiónFiltro DE Aire Vea la Fig MotorCaja DE Engranajes Para Cambiar EL Aceite DEL Motor Vea la FigLimpieza Servicio Y AjustesPara Cambiar LA Correa DE Impulsión Vea la Figs Mango Vea la Figs y AlmacenamientoPara Ajustar EL Mango Vea la Fig CarburadorSistema DE Combustible OtrosAceite DEL Motor CilindroProblema Causa Corrección Identificacion DE ProblemasKEY Part NO. NO. Description Gearcase Assembly Part NumberPage 532 42 KEY Part DescriptionPage KEY Part Description Warranty Statement Déclaration DE Garantie RÉF Piéce Description Page Ensemble du Boîtier de Tondeuse à Gazon Page Solution Cause Problème Dépannage DE Guide408029 Pièce DE Numéro Vitesse DE Boîte LA DE Ensemble Entreposage AutresStop ’ESSENCE Système Gazon À TondeuseCylindre Moteur DE HuileFigs les Voir D’ENTRAÎNEMENT Réglages ET RévisionMoteur Fig Voir Guidon LE Régler PourEntretien Gazon À Tondeuse’ENTRAÎNEMENT Courroie LA DE Couvercle LE Sous Nettoyer Fig Voir AIR À Filtre MoteurNettoyage ’ALLUMAGE BougieMotrices Roues Lame DE SoinVitesse DE Boîte HERBE-RAMASSEUtilisation Chaque Avant Générales RecommandationsLubrification DE Tableau LubrificationMoteur LE Démarrer Pour UtilisationBROYER/TONDRE DE Conseils Tondre DE Conseils11 .FIG Moteur LE Démarrer DE Avant10 et 9 .Figs les Voir HERBE-RAMASSE LE Vider PourTondeuse LA Convertir Pour Figs les VoirVotre Utiliser Comment Fig Voir D’ENTRAÎNEMENT Commande LA DE RéglagesFig Voir D’ENTRAÎNEMENT Commande Gazon À SedeutonCpsc Sécurité DE Normes DES Exigences LES Rencontre Gazon À Tondeuse Votre SUR ConnaissezCarton DU Gazon MontageZonga À Sedeuton Votre Monter CommentGénérale Entretien SommaireClient DU Responsabilités Produit DE SpécificationsTespen LES Dans Fonctionnement Carburant DU Sûre ManipulationEnfants Général FonctionnementPropriétaire du Manuel
Top Page Image Contents