Porter-Cable H1000IS-W instruction manual Eng

Page 13

5.Place skyhook on the fuel tank side of the frame and install upper bracket as shown.

6.Wrap upper bracket around frame.

7.Slide lockwashers onto bolts, insert through brackets, and secure with whizlock nuts. NOTE: DO NOT tighten bolts at this time.

8.Repeat steps 5-7 on other side.

9Position skyhook between arrows on label. NOTE: Bracket should not overlap onto weld.

Failure to properly position skyhook

can cause property damage, serious injury or death, and void the manufacturer’s warranty.

10.Torque four bolts to 11-12 ft.-lbs. (132-144 in.-lbs.)

IMPORTANT: DO NOT substitute hardware when assembling the skyhook.

11.Place tank on frame rails and align holes in tank with holes in frame.

12.Install fuel tank screws and wash- ers. Torque screws to 20-25 inch pounds (hand tight).

13.Open the fuel shut-off valve. Turn counter clockwise until the valve stops.

13- ENG

A01296

Image 13

Contents Generator Consumer Safety Information Safety Guidelines / DefinitionsImportant Safety Instructions Risk of Electrocution and FireRisk of Electrocution and Fire When installing a DoubleBe used OperationUnit Indoors or in ANY Risk of FireConfined Area Risk of Breathing Inhalation Hazard Risk of Unsafe Operation Risk of Moving Parts Risk of HOT SurfacesRisk from Lifting Specifications Consumer General and Service InformationAssembly Read and understand all safety warningsAssemble Wheel KIT UnpackingHole in Axle Without the holeExtended Hub ENG Assemble Skyhook ENG Grounding the Generator Extension Cord Wire Gauge Chart Amperage Length Size Double Throw Transfer SwitchObtaining Electricity from the Generator Extension CordsOperation 12V DC Outlet Idle ControlBefore Start UP Choose the correct applicationTo Start the Engine Connecting Electrical LoadsStopping Engine Engine speed has been factory set to provide safe operationConnecting Procedure for Raising or Suspending Generator Maintenance Storage BatteryEngine Preparation GeneratorDetermining Wattage Requirements Wattage CalculationsRunning Watts Starting Watts 250 500 Starting Wattage Requirements1000 Appliance or Load Device Typical Device Wattage Total Household Wattage CalculatorStart Troubleshooting GuideResponsibility of Original Purchaser initial User Limited WarrantyENG Quick Facts