Scag Power Equipment STT61V-25KBD manual Battery, Engine Air Cleaner

Page 39

Section 7

R

B. Replacing In-Line Fuel Filter Elements

- NOTE -

The fuel filter is located below the air filter. Figure 7-5 is for illustration purposes only.

The in-line pre-filter (Kubota engine only) and the engine fuel filter (Figure 7-5) should be replaced after every 500 hours of operation or annually, whichever occurs first.

1.Close the shut-off valve.

2.Remove and replace the engine fuel filter. Open the fuel shut-off valve.

7.7 Battery

WARNING

Lead-acid batteries produce flammable and explosive gases. To avoid personal injury when checking, testing or charging batteries, DO NOT use smoking materials near batteries. Keep arcs, sparks and flames away from batteries. Provide proper ventilation and wear safety glasses.

7.6 Engine Air Cleaner

A. Cleaning and/or Replacing Air Cleaner Element

For any air cleaner, the operating environment dictates the air cleaner service periods. To make it convenient for you we have installed an "Air Cleaner Indicator" which is located just behind the air filter. The indicator window will turn red when it is time to service the air filter. Do not service the filter unless this indicator is red.

- NOTE -

In extremely dusty conditions it may be necessary to check the indicator daily to prevent engine damage.

1.Snap open the two clips securing the air cleaner cover to the air cleaner box. Remove the air cleaner cover, clean the duck bill vent of any dust and set the cover aside.

2.Remove the air cleaner element and inspect.

3.Clean or replace the element as recommended by the engine manufacturer.

4.Replace the air filter cover and be sure to snap the two clips closed.

5.Reset the air cleaner indicator by pushing the button on the end of the indicator. The indicator window should return to clear.

WARNING

Battery posts, terminals, and related accessories contain lead and lead compounds, chemicals known to cause cancer and reproductive harm. Wash hands after handling.

WARNING

Electric storage battery fluid contains sulfuric acid which is POISON and can cause SEVERE CHEMICAL BURNS. Avoid contact of fluid with eyes, skin, or clothing. Use proper protective gear when handling batteries. DO NOT tip any battery beyond 45° angle in any direction. If fluid contact does occur, follow first aid suggestions below.

BATTERY ELECTROLYTE FIRST AID

External Contact — Flush with water.

Eyes — Flush with water for at least 15 minutes and get medical attention immediately.

Internal — Drink large quantities of water. Follow with Milk Of Magnesia, beaten egg, or vegetable oil. Get medical attention immediately. In case of internal contact, DO NOT give fluids that would induce vomiting.

35

Page 38 Page 40
Image 39
Page 38 Page 40
Contents OPERATOR’S Manual STT61V-28CAT-SS Remember Your Mower is only AS Safe AS the OperatorTable of Contents Adjustments Parking Brake Adjustment Travel Adjustments Servicing The Engine and Drive TraiN Components General InformationIntroduction Direction ReferenceSymbol Description SymbolsSafety Information Signal WordsBefore Operation considerations Operation Considerations Section Foldable Roll-Over Protection System Roll-over protection systemSeat Belt Inspection Using a spark arrestor Maintenance Considerations & storageDiesel Fuel only Safety and Instructional DecalsElectrical SpecificationsPower head EngineSMT61V Weights and DimensionsCutter Deck Hydraulic SystemControls and Instrument Identification Operating InstructionsDump Valve Control Safety Interlock SystemStarting the Engine Ground Travel and SteeringForward Travel Reverse Travel Engaging the Deck Drive Cutter BladesAfter Operation Rotating BladesHillside Operation Parking the MowerAdjusting Cutting Height Moving Mower with Engine StoppedRecommendations for Mowing Adjusting the Steering Levers Adjusting the Height Adjust PedalTowing optional hitch accessory Condition Cause Cure Troubleshooting Cutting ConditionsCut, or Rough Contour Troubleshooting Cutting Conditions ContdScalping Blades Hitting Parking Brake Adjustment AdjustmentsNeutral Adjustment Travel AdjustmentsThrottle Control and Choke Adjustments Belt AdjustmentTracking Adjustment Cutter Deck Pitch Cutter Deck AdjustmentsBelt Alignment Cutter Deck LevelCutter Deck Stop Cutter Deck HeightCustom-Cut Baffle Adjustment Custom-Cut Baffle AdjustmentClutch Air Gap Adjustment Electric clutch adjustmentMaintenance Chart Recommended Service Intervals MaintenanceLubrication Maintenance Chart Recommended Service Intervals ContdLubrication Fitting Points Changing Hydraulic Oil Checking Hydraulic Oil LevelEngine Fuel System Engine OilReplacing In-Line Fuel Filter Elements BatteryEngine Air Cleaner Cleaning and/or Replacing Air Cleaner ElementJump Starting Charging the BatteryCutter Blades Blade InspectionBlade Replacement TiresBlade Sharpening Changing Lubricant Cutter Deck GearboxCooling System Checking Lubricant LevelCleaning the Radiator Debris Screen BODY, DECK, and UpholsteryChecking The Fan Belt Tension Scag Approved Attachments and Accessories Illustrated Parts ListIllustrated Parts List Section 61V & 72V Cutter Deck Description Cutter Deck Controls 481764 Link, Deck Lift Sheet Metal Components Sheet Metal Components Section STT ROLL-OVER Protection System with Suspension Seat 9292 Deck Drive Components Deck Drive Components Engine & Attaching Parts CAT Diesel Available through the individual engine manufacturer Radiator & Attaching Parts CAT Diesel Radiator & Attaching Parts CAT Diesel Engine & Attaching Parts Kubota Diesel 424633 Latch, Hood Brake and Steering Components Brake and Steering Components Fuel and Hydraulic System CAT Diesel Fuel and Hydraulic System CAT Diesel Fuel and Hydraulic System Kubota Diesel Hose Assy, 1/2 ID Tank to Filter Base Section BDP-16A Hydraulic Pump Assembly with Cooling Fan Hex Screw, Flanged Head M10 x 1.50-65mm Electrical System CAT Diesel Electrical System CAT Diesel Electrical System Kubota Diesel 483643 Cover, Sealed Single 483641 Manufactured Under ONE or More Replacement Decals and Information PlatesSttkbd Decals Page2 COM Electrical Schematic CAT DieselGlow Plug POS NEG Volt Meter PTO Switch Module Relay Electrical Schematic Kubota DieselLimited Warranty Commercial Equipment
Top Page Image Contents