Honda Power Equipment TPG-7000H-DXE, TPG-2900H-DX manual Using the Generator, AC Application

Page 21

Tsurumi’s Operation, Service, and Repair Manual

NOTE:

•The choke may not be needed if the engine is warm or the air temperature is high.

(3)Move the throttle lever slightly to the left.

(4)(MODEL TPG-7000H-DXE ONLY): To start the engine using the electric starter, proceed as follows:

(a)Turn key in engine START/STOP switch.

(b)Turn key fully right to START position. Hold in START position until engine starts.

(c)Release key; the key is spring-loaded to the RUN position.

(d)As the engine warms up, gradually move the choke lever to the OPEN position.

(e)Position the throttle lever at the desired engine speed.

(5)(ALL MODELS): When starting the engine using recoil starter, proceed as follows:

(a)Turn the engine switch to the ON position.

(b)Pull the starter grip lightly until resistance is felt, then pull briskly.

NOTE:

•When using the recoil starter, do not allow the starter grip to snap back against the engine. Return it gently to prevent damage to the starter.

(c)As the engine warms up, gradually move the choke lever to the OPEN position.

(d)Position the throttle lever at the desired engine speed.

G. USING THE GENERATOR

WARNING:

•TO PREVENT ELECTRICAL SHOCK FROM FAULTY APPLIANCES, THE GENERATOR SHOULD BE GROUNDED. CONNECT A LENGTH OF HEAVY WIRE BETWEEN THE GENERA- TOR’S GROUND TERMINAL AND EXTERNAL GROUND SOURCE.

•CONNECTIONS FOR STANDBY POWER TO A BUILDING’S ELECTRICAL SYSTEM MUST BE MADE BY A QUALIFIED ELECTRICIAN AND MUST COMPLY WITH ALL APPLICABLE LAWS AND ELECTRICAL CODES. IMPROPER CONNECTIONS CAN ALLOW ELECTRICAL CUR- RENT FROM THE GENERATOR TO BACK-FEED INTO THE UTILITY LINES. SUCH BACK- FEED MAY ELECTROCUTE UTILITY COMPANY WORKERS OR OTHERS WHO CONTACT THE LINES DURING A POWER OUTAGE, AND WHEN UTILITY POWER IS RESTORED, THE GENERATOR MAY EXPLODE, BURN, OR CAUSE FIRES IN THE BUILDING’S ELECTRICAL SYSTEM.

H.AC APPLICATION

ASingle Voltage Type

(1)Check the pilot lamp for proper voltage.

NOTE:

•The generator is thoroughly tested and adjusted in the factory. If the generator does not produce the specific voltage, consult your nearest Tsurumi Generator dealer.

(2)Set switches on the electrical appliances to OFF before connecting to the generator.

(3)Insert the plug of the electrical appliance into the appropriate receptacle.

Operating Instructions

Page 18

Page 20 Page 22
Image 21
Page 20 Page 22
Contents OPERATION, SERVICE, Limited Warranty Table of Contents TPG-7000H-DXE IntroductionPrecautions and Placards Data Plate AIR Cleaner Maintenance HOT Muffler & Exhaust PlacardFuel Warning Placard 120VSafety Precautions SPECIFICATIONS/KEY Features Description and Operation Physical DescriptionDescription of the Portable Generator Cutaway of Generator Model TPG-2900H-DX Shown Description of GeneratorDescription of the Engine Description of the Fuel TankDescription of the Front Panel Functional Description Generation of No-Load Voltage refer to FigureVoltage Fluctuations Under Load refer to Figure Full Power Switch Circuit Diagram Full Power Switch Dual Voltage Type refer to FigureFull Power Switch Set for Single-Voltage Output Operating Instructions Operating ControlsDC Circuit Controls Model TPG-2900H-DX Model TPG-6000H-DX Check the Engine OIL Level DC Circuit Reset PushbuttonChecking Oil Level Check Engine FuelStarting & Operating the Engine PRE-START ChecksAC Application Using the GeneratorTsurumi’s Operation, Service, and Repair Manual Stopping the Generator Available Receptacles With Full Power Switch OnIdle Control TPG-4300H-DX, TPG-6000H-DX, and TPG-7000H-DXE OIL AlertStopping the Engine Wattage InformationWattage Chart Check motor starting current and power factor carefullyMaintenance Schedule MaintenanceChanging Engine OIL AIR Cleaner ServiceCleaning and Adjusting Spark Plug Sediment CUP CleaningSpark Plug Gap Isolating Fault to the Generator or to the Control Panel TroubleshootingElectrical Limits Reference Chart Fault Isolation Procedures Troubleshooting ChartsRefer to Component Replacement for Tsurumi’s Operation, Service, and Repair Manual Tsurumi’s Operation, Service, and Repair Manual Tsurumi’s Operation, Service, and Repair Manual Tsurumi’s Operation, Service, and Repair Manual Wiring Diagram Model TPG-2900H-DX Wiring DiagramsControl BOX Wiring Diagram Model TPG-4300H-DXWiring Diagram Model TPG-6000H-DX Wiring Diagram Model TPG-7000H-DXE Fastener Torque Values REMOVAL/INSTALLATIONReplacement of Battery Battery Enclosure Components REMOVAL/INSTALLATION of Battery EnclosureBattery Enclosure Exploded View Replacement of Engine MufflerReplacement of Engine Muffler Model TPG-2900H-DX Replacement of Muffler Model TPG-2900H-DX Replacement of Fuel Tank Fuel Shutoff Valve Shown in Closed Position Draining Fuel from Fuel Tank REMOVAL/INSTALLATION of the Engine and Generator AS a UnitTsurumi’s Operation, Service, and Repair Manual Tsurumi’s Operation, Service, and Repair Manual Removal of Engine and Generator as a Unit Replacement of Stator Replacement of Generator StatorReplacement of Rotor Bearing Bearing Puller in Use Replacement of RotorRemoval of Through Bolt Wrapping Bolt with Tape Front Cover Bolts Replacement of Rotor BearingRemoval/Installation of Front Panel and Control Box Replacement of Front Panel ComponentsFront Panel and Control Box Components Tsurumi’s Operation, Service, and Repair Manual 72.2 Tsurumi’s Operation, Service, and Repair Manual Storage Instructions Never USE Water to Clean GeneratorReplacement Parts IntroductionOrdering Parts Exploded View Generator Model TPG-2900H-DX Part Number Description Qty Parts List Generator Model TPG-2900H-DXExploded View Front Panel Model TPG-2900H-DX Part Number Description Qty Parts List Front Panel Model TPG-2900H-DXExploded View Generator Model TPG-4300H-DX Parts List Generator Model TPG-4300H-DX Exploded View Front Panel Model TPG-4300H-DX GF53BKA Parts List Front Panel Model TPG-4300H-DXExploded View Generator Model TPG-6000H-DX Parts List Generator Model TPG-6000H-DX Exploded View Front Panel Model TPG-6000H-DX IEGBX6620 Parts List Front Panel Model TPG-6000H-DXExploded View Generator Model TPG-7000H-DXE Parts List Generator Model TPG-7000H-DXE Exploded View Front Panel Model TPG-7000H-DXE IEGBX6622 Parts List Front Panel Model TPG-7000H-DXEParts List Battery Enclosure Model TPG-7000H-DXE A-1 Appendix a Check KIT Contents Installation of Battery Enclosure Appendix B PGWK-100 Wheel KIT Installation Instructions KIT Contents View B Install Axle on GeneratorAppendix C PGWK-200 Wheel KIT Installation Instructions Wheel Kit Parts Include Product FeaturesInstall Axle Assembly and Wheels

TPG-4300H-DX, TPG-6000H-DX, TPG-7000H-DXE, TPG-2900H-DX specifications

Honda Power Equipment has long been synonymous with reliability and innovation in the realm of portable power solutions. Among its impressive lineup, the TPG series showcases a range of generators designed to meet diverse power requirements. The TPG-7000H-DXE, TPG-2900H-DX, TPG-6000H-DX, and TPG-4300H-DX are standout models equipped with cutting-edge technologies, exceptional features, and robust characteristics.

The TPG-7000H-DXE is a powerhouse, providing a maximum output of 7000 watts. This generator is equipped with a Honda GX390 engine, known for its durability and fuel efficiency. A key feature is its advanced inverter technology, which delivers clean and stable power, making it suitable for sensitive electronic devices. Additionally, the unit is designed with a large fuel tank, enabling extended runtimes and reducing the frequency of refueling. Portability is another hallmark of the TPG-7000H-DXE, featuring ergonomic handles and wheels for easy transport.

Next in line, the TPG-2900H-DX is a compact yet powerful generator, ideal for recreational activities or as a backup power source. With a maximum output of 2900 watts, this model also incorporates an inverter system to ensure clean power delivery. It boasts low noise levels, making it a perfect choice for camping or tailgating. The ease of use is enhanced by its straightforward control panel and electric start option, allowing users to power up quickly and efficiently.

The TPG-6000H-DX offers a balance between power and portability, with a maximum output of 6000 watts. This generator features an innovative automatic voltage regulator that ensures stability across varying loads. The design includes a heavy-duty frame that provides durability while safeguarding internal components. With its versatile outlet configuration, users can connect multiple devices simultaneously, making it ideal for job sites or home use.

Lastly, the TPG-4300H-DX targets users who require reliable power in a mid-range class. This model delivers 4300 watts and incorporates user-friendly features like a simple recoil start and low-oil shutdown for engine protection. Its compact design and robust wheels facilitate easy movement, while the durable construction ensures it withstands diverse weather conditions.

In summary, Honda's TPG series exemplifies excellence in power generation, featuring advanced technology, engineered for robustness, and tailored for versatility. Whether for backup power, recreational use, or professional applications, models like the TPG-7000H-DXE, TPG-2900H-DX, TPG-6000H-DX, and TPG-4300H-DX meet the power demands of today's users.
Top Page Image Contents