Honda Power Equipment TPG-2900H-DX manual OIL Alert, Stopping the Engine, Wattage Information

Page 24

Tsurumi’s Operation, Service, and Repair Manual

J.OIL ALERT

(1)The oil alert detects the fall in oil level in the crankcase and automatically stops the engine when the oil level falls down below the predetermined level.

(2)When the engine has stopped automatically, check the oil level. Refill engine oil to the upper level and restart the engine.

(3)If the engine does not start by usual starting procedures, check the oil level.

K.IDLE CONTROL (TPG-4300H-DX, TPG-6000H-DX, AND TPG-7000H-DXE)

The idle control feature automatically reduces engine speed when there is no load on the generator and automatically increases engine speed up to rated speed when load is applied.

The idle control feature provides fuel economy and low noise operation at no-load running.

(1)How To Use Idle Control

(a)Start the engine with IDLE switch set to OFF.

NOTE:

•Warm up the engine without a load for a few minutes.

(b)Set IDLE switch to the ON position.

(2)Checking Idle Function

(a)When the idle function does not operate normally, please check the following:

NOTE:

•Most induction loads, such as an electric motor, require wattage three to five times larger than their rating at starting. This starting wattage should not exceed the rated output of the generator.

(b)Is the generator overloaded? Make sure that the generator is not overloaded.

(c)Turn the IDLE switch off when the idle control does not work normally under the rated output.

L.STOPPING THE ENGINE

(1)Turn off the switch of load or disconnect the load.

(2)Turn the IDLE switch off.

(3)Push ENGINE to stop.

NOTE:

•Allow the engine about 3 minutes to cool down at no-load before stopping.

M. WATTAGE INFORMATION

When starting some appliances, a “surge” of energy occurs. Depending upon the nature of the elec- trical load, the amount of electrical power needed to start the appliance may exceed the amount need- ed to maintain its use. See Table 4 for appliances you may use with this generator.

Electrical appliances and tools normally come with a label indicating voltage, cycles/Hz, amperage (amps) and electrical power needed to run the appliance or tool. Check with your nearest dealer with questions regarding power surge of certain appliances or power tools.

Page 21

Operating Instructions

Page 23 Page 25
Image 24
Page 23 Page 25
Contents OPERATION, SERVICE, Limited Warranty Table of Contents Introduction TPG-7000H-DXEPrecautions and Placards AIR Cleaner Maintenance HOT Muffler & Exhaust Placard Data PlateFuel Warning Placard 120VSafety Precautions SPECIFICATIONS/KEY Features Description and Operation Physical DescriptionDescription of the Portable Generator Description of Generator Cutaway of Generator Model TPG-2900H-DX ShownDescription of the Engine Description of the Fuel TankDescription of the Front Panel Functional Description Generation of No-Load Voltage refer to FigureVoltage Fluctuations Under Load refer to Figure Full Power Switch Dual Voltage Type refer to Figure Full Power Switch Circuit DiagramFull Power Switch Set for Single-Voltage Output Operating Instructions Operating ControlsDC Circuit Controls Model TPG-2900H-DX Model TPG-6000H-DX DC Circuit Reset Pushbutton Check the Engine OIL LevelCheck Engine Fuel Checking Oil LevelPRE-START Checks Starting & Operating the EngineUsing the Generator AC ApplicationTsurumi’s Operation, Service, and Repair Manual Available Receptacles With Full Power Switch On Stopping the GeneratorOIL Alert Idle Control TPG-4300H-DX, TPG-6000H-DX, and TPG-7000H-DXEStopping the Engine Wattage InformationCheck motor starting current and power factor carefully Wattage ChartMaintenance Maintenance ScheduleAIR Cleaner Service Changing Engine OILSediment CUP Cleaning Cleaning and Adjusting Spark PlugSpark Plug Gap Troubleshooting Isolating Fault to the Generator or to the Control PanelElectrical Limits Reference Chart Troubleshooting Charts Fault Isolation ProceduresRefer to Component Replacement for Tsurumi’s Operation, Service, and Repair Manual Tsurumi’s Operation, Service, and Repair Manual Tsurumi’s Operation, Service, and Repair Manual Tsurumi’s Operation, Service, and Repair Manual Wiring Diagrams Wiring Diagram Model TPG-2900H-DXWiring Diagram Model TPG-4300H-DX Control BOXWiring Diagram Model TPG-6000H-DX Wiring Diagram Model TPG-7000H-DXE REMOVAL/INSTALLATION Fastener Torque ValuesReplacement of Battery REMOVAL/INSTALLATION of Battery Enclosure Battery Enclosure ComponentsReplacement of Engine Muffler Battery Enclosure Exploded ViewReplacement of Engine Muffler Model TPG-2900H-DX Replacement of Muffler Model TPG-2900H-DX Replacement of Fuel Tank Fuel Shutoff Valve Shown in Closed Position REMOVAL/INSTALLATION of the Engine and Generator AS a Unit Draining Fuel from Fuel TankTsurumi’s Operation, Service, and Repair Manual Tsurumi’s Operation, Service, and Repair Manual Removal of Engine and Generator as a Unit Replacement of Generator Stator Replacement of StatorReplacement of Rotor Bearing Replacement of Rotor Bearing Puller in UseRemoval of Through Bolt Wrapping Bolt with Tape Replacement of Rotor Bearing Front Cover BoltsReplacement of Front Panel Components Removal/Installation of Front Panel and Control BoxFront Panel and Control Box Components Tsurumi’s Operation, Service, and Repair Manual 72.2 Tsurumi’s Operation, Service, and Repair Manual Never USE Water to Clean Generator Storage InstructionsReplacement Parts IntroductionOrdering Parts Exploded View Generator Model TPG-2900H-DX Parts List Generator Model TPG-2900H-DX Part Number Description QtyExploded View Front Panel Model TPG-2900H-DX Parts List Front Panel Model TPG-2900H-DX Part Number Description QtyExploded View Generator Model TPG-4300H-DX Parts List Generator Model TPG-4300H-DX Exploded View Front Panel Model TPG-4300H-DX Parts List Front Panel Model TPG-4300H-DX GF53BKAExploded View Generator Model TPG-6000H-DX Parts List Generator Model TPG-6000H-DX Exploded View Front Panel Model TPG-6000H-DX Parts List Front Panel Model TPG-6000H-DX IEGBX6620Exploded View Generator Model TPG-7000H-DXE Parts List Generator Model TPG-7000H-DXE Exploded View Front Panel Model TPG-7000H-DXE Parts List Front Panel Model TPG-7000H-DXE IEGBX6622Parts List Battery Enclosure Model TPG-7000H-DXE A-1 Appendix a Check KIT Contents Installation of Battery Enclosure Appendix B PGWK-100 Wheel KIT Installation Instructions KIT Contents Install Axle on Generator View BAppendix C PGWK-200 Wheel KIT Installation Instructions Product Features Wheel Kit Parts IncludeInstall Axle Assembly and Wheels

TPG-4300H-DX, TPG-6000H-DX, TPG-7000H-DXE, TPG-2900H-DX specifications

Honda Power Equipment has long been synonymous with reliability and innovation in the realm of portable power solutions. Among its impressive lineup, the TPG series showcases a range of generators designed to meet diverse power requirements. The TPG-7000H-DXE, TPG-2900H-DX, TPG-6000H-DX, and TPG-4300H-DX are standout models equipped with cutting-edge technologies, exceptional features, and robust characteristics.

The TPG-7000H-DXE is a powerhouse, providing a maximum output of 7000 watts. This generator is equipped with a Honda GX390 engine, known for its durability and fuel efficiency. A key feature is its advanced inverter technology, which delivers clean and stable power, making it suitable for sensitive electronic devices. Additionally, the unit is designed with a large fuel tank, enabling extended runtimes and reducing the frequency of refueling. Portability is another hallmark of the TPG-7000H-DXE, featuring ergonomic handles and wheels for easy transport.

Next in line, the TPG-2900H-DX is a compact yet powerful generator, ideal for recreational activities or as a backup power source. With a maximum output of 2900 watts, this model also incorporates an inverter system to ensure clean power delivery. It boasts low noise levels, making it a perfect choice for camping or tailgating. The ease of use is enhanced by its straightforward control panel and electric start option, allowing users to power up quickly and efficiently.

The TPG-6000H-DX offers a balance between power and portability, with a maximum output of 6000 watts. This generator features an innovative automatic voltage regulator that ensures stability across varying loads. The design includes a heavy-duty frame that provides durability while safeguarding internal components. With its versatile outlet configuration, users can connect multiple devices simultaneously, making it ideal for job sites or home use.

Lastly, the TPG-4300H-DX targets users who require reliable power in a mid-range class. This model delivers 4300 watts and incorporates user-friendly features like a simple recoil start and low-oil shutdown for engine protection. Its compact design and robust wheels facilitate easy movement, while the durable construction ensures it withstands diverse weather conditions.

In summary, Honda's TPG series exemplifies excellence in power generation, featuring advanced technology, engineered for robustness, and tailored for versatility. Whether for backup power, recreational use, or professional applications, models like the TPG-7000H-DXE, TPG-2900H-DX, TPG-6000H-DX, and TPG-4300H-DX meet the power demands of today's users.
Top Page Image Contents