Briggs & Stratton 30219 manual Changing Engine Oil, Clean/Replace Spark Plug

Page 15

MAINTENANCE

To service the air cleaner, follow these steps:

1.Loosen screws and remove air cleaner cover. Remove paper filter (Figure 11).

Figure 11 - Air Cleaner

 

Cartridge

Cover

 

Screw

Base

2.Install clean (or new) air cleaner assembly inside cover. Dispose of old filter properly.

3.Assemble air cleaner cover onto base and tighten screws.

Changing Engine Oil

Change the oil after the first 5 hours of operation. Change oil every 50 hours thereafter. If you are using your generator under extremely dirty or dusty conditions, or in extremely hot weather, change the oil more often.

CAUTION

Avoid prolonged or repeated skin contact with used motor oil.

•Used motor oil has been shown to cause skin cancer in certain laboratory animals.

•Thoroughly wash exposed areas with soap and water.

KEEP OUT OF REACH OF CHILDREN. DON'T POLLUTE. CONSERVE RESOURCES. RETURN USED OIL TO COLLECTION CENTERS.

Change the oil while the engine is still warm from running, as follows:

1.Make sure unit is on a level surface.

2.Disconnect the spark plug wire from the spark plug and place the wire where it cannot contact spark plug.

3.Clean area around oil drain plug.The oil drain plug is located at base of engine, opposite carburetor.

4.Remove oil drain plug and drain oil completely into a suitable container.

5.Reinstall oil drain plug and tighten securely. Remove oil fill cap.

6.Slowly pour oil (about 20 oz.) into oil fill opening to the point of overflowing at oil fill. DO NOT overfill.

7.Reinstall oil fill cap. Finger tighten cap securely.

8.Wipe up any spilled oil.

Clean/Replace Spark Plug

Change the spark plug every 100 hours of operation or once each year, whichever comes first.This will help your engine to start easier and run better.

1.Clean area around spark plug.

2.Remove and inspect spark plug.

3.Check electrode gap with wire feeler gauge and set spark plug gap to 0.030 inch (0.76mm) if necessary (Figure 12).

Figure 12 — Service Spark Plug

4.Replace spark plug if electrodes are pitted, burned or porcelain is cracked. Use a recommended replacement plug.

5.Install spark plug and tighten firmly.

Clean Spark Arrester Screen

The engine exhaust muffler has a spark arrester screen. Inspect and clean the screen every 100 hours of operation or once each year, whichever comes first.

If you use your generator on any forest-covered, brush- covered, or grass-covered unimproved land, it must have a spark arrester.The spark arrester must be maintained in good condition by the owner/operator.

15

Page 14 Page 16
Image 15
Page 14 Page 16
Contents Starting Watts Operator’s Manual Manual del OperarioCall Generator Helpline Llame Línea Directa del Generador Table of Contents Safety RulesEquipment Description When Transporting or Repairing Equipment When Adding or Draining FuelWhen Starting Equipment When Operating EquipmentWhen Testing for Engine Spark When Adjusting or Making Repairs to Your GeneratorKnow Your Generator Unpacking the Generator AssemblyInstall Wheel Kit Refer to and install the wheel kit as followsType of Fuel Before Starting EngineAdd Engine Oil Add FuelGenerator Location Using the GeneratorConnecting to a Building’s Electrical System System GroundStarting the Engine Operating GeneratorStopping the Engine Connecting Electrical LoadsReceptacles Generator Adapter Cord SETExample Power ManagementDont Overload Generator CapacityEngine Specifications Product SpecificationsGenerator Specifications Power RatingsGenerator Maintenance Generator CleaningGeneral Recommendations Engine Maintenance Service Air CleanerOil Changing Engine Oil Clean/Replace Spark PlugClean Spark Arrester Screen To service the air cleaner, follow these stepsCarburetor Adjustment Clean and inspect the spark arrester as followsAir Cooling System Generator StorageLong Term Storage Instructions Protect Fuel SystemTroubleshooting Page Owner’s Warranty Responsibilities Emissions Control System WarrantyPage Page Limited Warranty Advertencia Tabla DE ContenidosDescripción DEL Equipo Reglas DE SeguridadCuando Transporte O Repare EL Equipo Cuando Añada Combustible O Vacíe EL DepósitoCuando Ponga EN Funcionamiento EL Equipo Cuando Opere EL EquipoPrecaución Cuando Ajuste O Haga Reparaciones a SU GeneradorCuando Pruebe LA Bujía DEL Motor Conozca SU Generador Tapa del Depósito del Aceite Llene el motor con aceiteTomacorriente Dobles de 120 Voltios AC, 20 Amp Montaje Desembalaje del GeneradorInstale el Juego de Ruedas Cuando Añada Combustible Antes DE Darle Arranque AL MotorAgregar Aceite al Motor Agregue CombustibleUbicación del Generador USO DEL GeneradorTierra del Sistema Conexión al Sistema Eléctrico de un EdificioEncienda el Motor Operando EL GeneradorParado Del Motor Juego DE Cables DEL Adaptador DEL GeneradorReceptáculos Precaución Conexion De Cargas ElectricasEjemplo No Sobrecargue GeneradorCapacidad Control de la EnergíaPotencia Nominal Información Técnica Sobre EL MotorEspecificaciones DEL Producto Especificaciones del GeneradorLimpieza del Generador Recomendaciones GeneralesMantenimiento DEL GeneradorMantenimiento DEL Motor Advertencia AceiteServicio del Depurador de Aire Limpie/Reemplace la Bujía Cambio de Aceite del MotorLimpie la Pantalla Apagachispas Sistema de Refrigeración de Aire Ajuste del CarburadorLimpie e inspeccione el apagachispas de la siguiente manera Generador AlmacenamientoAlmacenamiento Para Periodos Prolongados Proteja el Sistema de CombustibleDiagnositicos DE Averías Problemo Causa AccionNotas Garantía DEL Sistema DE Control DE Emisiones = 250 horas, B = 500 horas y a = 1000 horas Uso comercial Uso del consumidor

30219 specifications

The Briggs & Stratton 30219 is a highly regarded gasoline-powered generator that epitomizes reliability and performance for both residential and small commercial applications. This model is particularly popular among homeowners who require a dependable source of backup power during outages or those who want to power outdoor events and tools.

One of the standout features of the Briggs & Stratton 30219 is its impressive power output. With a 3,200 running watts and a peak output of 3,750 watts, it is capable of powering essential home appliances, such as refrigerators, heating systems, and quickly rechargeable devices. This capability makes it an excellent choice for emergency power solutions, ensuring that users can maintain comfort and functionality during unexpected power interruptions.

At the heart of the 30219 generator is a robust engine designed for longevity and efficiency. The 162cc OHV (Overhead Valve) engine provides a strong performance while maintaining fuel efficiency, allowing users to maximize their runtime. This generator is engineered with a 1.5-gallon fuel tank, providing up to 8 hours of continuous operation at 50% load, which is essential when you need consistent power without frequent refueling.

In terms of portability, the Briggs & Stratton 30219 incorporates a compact and lightweight design. It is equipped with a sturdy handle and wheels, making it easy to transport from one location to another. This is particularly beneficial for users who may need to move the generator for outdoor activities, construction sites, or emergency situations.

Safety is also a vital concern for users during operation. The Briggs & Stratton 30219 is equipped with a built-in low-oil shutdown feature, which automatically turns off the engine when oil levels become too low. This helps to prevent engine damage and extends the life of the generator. Additionally, it includes multiple outlets, providing versatility for connecting various devices while ensuring that users can power multiple items simultaneously.

Overall, the Briggs & Stratton 30219 generator is a powerful, efficient, and portable solution suitable for a variety of power needs. With its durable construction, reliable performance, and user-friendly features, it continues to earn a reputation as one of the best choices on the market for those seeking dependable backup power. Whether experiencing an outage or powering outdoor activities, the 30219 generator stands ready to perform.
Top Page Image Contents