Briggs & Stratton Portable Generator manual Verify Engine Oil Level, Add Fuel, High Altitude

Page 8

Verify Engine Oil Level

The generator engine is shipped from the factory filled with oil (API SJ or higher 10W-30). This allows for generator operation in the widest range of temperature and climate conditions. Before starting the engine, check oil level and ensure that engine is serviced as described in Maintenance.

NOTE: See Oil in the Maintenance section to review oil recomendations. Verify provided oil in engine is the correct viscosity for current ambient temperature.

NOTICE

Any attempt to crank or start the engine before it has been properly filled with the recommended oil will result in equipment failure.

•Refer to Maintenance for oil fill information.

•Damage to equipment resulting from failure to follow this instruction will void warranty.

Add Fuel

Fuel must meet these requirements:

•Clean, fresh, unleaded gasoline.

•A minimum of 87 octane/87 AKI (91 RON). High altitude use, see High Altitude.

•Gasoline with up to 10% ethanol (gasohol) or up to 15% MTBE (methyl tertiary butyl ether) is acceptable.

NOTICE

Avoid generator damage.

Failure to follow Operator’s Manual for fuel recommendations voids warranty.

•DO NOT use unapproved gasoline such as E85.

•DO NOT mix oil in gasoline.

•DO NOT modify engine to run on alternate fuels.

To protect the fuel system from gum formation, mix in a fuel stabilizer when adding fuel. See Storage. All fuel is not the same. If you experience starting or performance problems after using fuel, switch to a different fuel provider or change brands. This engine is certified to operate on gasoline. The emission control system for this engine is EM (Engine Modifications).

WARNING

Fuel and its vapors are extremely flammable and explosive.

Fire or explosion can cause severe burns or death.

WHEN ADDING FUEL

•Turn generator OFF and let it cool at least 2 minutes before removing fuel cap. Loosen cap slowly to relieve pressure in tank.

•Fill fuel tank outdoors.

•DO NOT overfill tank. Allow space for fuel expansion.

•If fuel spills, wait until it evaporates before starting engine.

•Keep fuel away from sparks, open flames, pilot lights, heat, and other ignition sources.

•DO NOT light a cigarette or smoke.

1.Clean area around fuel fill cap, remove cap.

2.Slowly add unleaded gasoline (A) to fuel tank (B). Be careful not to overfill. Allow about 1.5" (4 cm) of tank space (C) for fuel expansion.

B

C

A

3.Install fuel cap and let any spilled fuel evaporate before starting engine.

High Altitude

At altitudes over 5,000 feet (1524 meters), a minimum

85 octane / 85 AKI (89 RON) gasoline is acceptable. To remain emissions compliant, high altitude adjustment is required. Operation without this adjustment will cause decreased performance, increased fuel consumption, and increased emissions. See an authorized dealer for high altitude adjustment information. Operation of the engine at altitudes below 2,500 feet (762 meters) with the high altitude kit is not recommended.

8

BRIGGSandSTRATTON.COM

Page 7 Page 9
Image 8
Page 7 Page 9
Contents Operator’s Manual Where to Find Us GeneratorEngine Date PurchasedTable of Contents Operator Safety Safety RulesSafety alert symbol is used with a signal word Hazard Symbols and MeaningsCertain components in this product and related Engine exhaust from this product containsGenerator produces hazardous voltage Broken bones, fractures, bruises, or sprains could resultUnintentional sparking can result in fire or electric shock When Testing for Engine SparkContact with muffler area can result in serious burns Assembly Install Wheel KitInstall the wheel kit as follows Unpack GeneratorWhen Adding Fuel Verify Engine Oil LevelAdd Fuel Fuel must meet these requirementsConnecting to a Building’s Electrical System System GroundGenerator Location Special RequirementsFeatures and Controls Volt AC, 20 Amp, Duplex Receptacles May beCord Sets and Receptacles Nema L14-30Generator Adapter Cord Set 120/240 Volt AC, 30 Amp, Locking ReceptacleOperation Starting the EngineMove fuel valve to Off position Connecting Electrical LoadsStopping the Engine Select the items you will power at the same time Power ManagementDon’t Overload Generator CapacityGenerator Maintenance MaintenanceMaintenance Schedule Engine Maintenance Oil Oil RecommendationsChecking Oil Level Adding Engine OilService Air Cleaner Service Spark PlugInstall spark plug and tighten firmly Service Spark ArresterClean and inspect the spark arrester as follows Clean Cooling SystemCarburetor Adjustment Check Valve ClearanceStorage Troubleshooting Warranties Emissions Control System WarrantyOwner’s Warranty Responsibilities Claims and Coverage Exclusions MaintenanceEmission Information Limited Warranty Product Specifications Common Service PartsAC Load Current 800Manual del Operario Dónde encontrarnos GeneradorMotor Fecha de compraResolución de problemas Garantías Seguridad de operarioMontaje Controles y característicasSeguridad de operario Descripción del equipoReglas de seguridad Símbolos de peligro y sus significadosDeterminados componentes en este producto y los Declaradas cancerígenas, causantes deCuando Ajuste O Haga Reparaciones a SU Máquina Generador Cuando Pruebe LA Bujía DEL MotorMontaje Desembalaje del generadorInstale el juego de ruedas Siga estos pasos para instalar el juego de ruedasComprobar el nivel de aceite del motor Agregue combustibleEl combustible debe reunir los siguientes requisitos Evite el daño del generadorTierra del sistema Conexión al sistema eléctrico de un edificioUbicación del generador Requisitos EspecialesControles y características Amperios, monofásica de 60 HzJuegos de cordones y enchufes conectores Juego de cables del adaptador del generadorDispositivo de seguridad de 120/240 V, 30 a Tomas eléctricas dobles de 120 V CA y 20 aOperando Encienda el motorConexión de cargas eléctricas Parada del motorEl motor podría petardear, incendiarse o dañarse Gire la válvula de combustible hasta la posición OffNo sobrecargar el generador CapacidadEjemplo Control de la energíaMantenimiento del generador MantenimientoPlan de mantenimiento Mantenimiento del motor Aceite Recomendaciones sobre el aceiteComprobación del nivel de aceite Adición de aceite del motorCarburador Servicio del depurador de aireServicio del bujía Limpie la pantalla apagachispasLimpie e inspeccione el apagachispas de la siguiente manera Sistema de refrigeración de aireComprobación de holgura de la válvula Ajuste del carburadorAlmacenamiento Resolución de problemas Garantías Garantía del sistema de control de emisionesResponsabilidades de la garantía del propietario Operaciones de mantenimiento que se enumeran en lasInformación sobre emisiones Garantía Limitada Corriente Carga de C.A Especificaciones del productoServicio común despide

Portable Generator specifications

Briggs & Stratton portable generators have become a trusted choice for both homeowners and professionals who need reliable power on the go. Known for their robust design and innovative features, these generators are engineered to deliver exceptional performance in various applications, from outdoor events to emergency backup during power outages.

One of the key features of Briggs & Stratton portable generators is their powerful engine options. Equipped with reliable four-stroke engines, these generators provide ample power to run essential appliances, tools, and equipment. Models like the Briggs & Stratton P4500 are especially praised for their inverter technology, which produces clean power suitable for sensitive electronics. This means users can confidently power laptops, TVs, and other sensitive devices without the risk of damage due to power surges.

Technology plays a pivotal role in enhancing the usability of Briggs & Stratton generators. The equipped PowerSmart Series technology allows for smart engine management, optimizing fuel efficiency while delivering consistent power output. This not only saves fuel but also extends the runtime, making them perfect companions for long camping trips or power outages.

Portability is another hallmark of Briggs & Stratton generators. Many units come with built-in handles and transport wheels, making it easy to move them from one location to another. Their lightweight yet durable construction ensures that even larger models can be handled by one or two people, providing convenience without sacrificing strength.

In terms of safety features, Briggs & Stratton portable generators are designed with user protection in mind. Many models include low-oil shutdown systems that automatically halt operation when oil levels drop dangerously low, preventing engine damage. Additionally, their built-in circuit breakers help avoid overloads, ensuring that the generator operates safely and efficiently.

Other noteworthy characteristics include easy-start engines, easy-access control panels, and multiple outlet options, which enhance their versatility for various types of users. With features such as USB outlets, users can charge personal electronics alongside their other power needs.

In summary, Briggs & Stratton portable generators stand out due to their power, efficiency, portability, and safety features. These generators are an essential investment for anyone seeking reliable power solutions, whether for recreational use, construction work, or emergency preparedness. With a legacy of quality and innovation, Briggs & Stratton continues to set a benchmark in the portable generator market.
Top Page Image Contents