Sharp AR-151 operation manual Osha PEL Acgih TLV

Date Issued :Nov. 1, 2000

MATERIAL SAFETY DATA SHEET

MSDS No. F-31001

Section 1. Product Identification

Product

AR-152ND/DV/SD (Black Developer)

Section 2. Supplier’s Name and Address

Sharp Corporation

22-22 Nagaike-cho, Abeno-ku, Osaka, Japan

Local suppliers are listed below. Please contact the nearest supplier for additional information.

(Country)	(Name and Telephone Number)
U.S.A.	Sharp Electronics Corporation
	Telephone number for information:	1-800-237-4277
	Emergency telephone number:	1-800-255-3924
Canada	Sharp Electronics of Canada Ltd.
	Telephone number for information:	905-890-2100
	Emergency telephone number:	1-800-255-3924
United Kingdom	Sharp Electronics (U.K.) Ltd.
	Telephone number for information: 01923-474013

Section 3.	Ingredients
Ingredients		CAS No.	Proportion	OSHA PEL	ACGIH TLV	Other Limits
Iron powder		7439-89-6	> 92.5%	Not listed	Not listed	None
Styrene-Acrylate copolymer		29497-14-1	< 7.0%	Not listed	Not listed	None
Carbon black		1333-86-4	< 0.5%	3.5mg/m3	3.5mg/m3	None

Section 4. Hazardous Identification (Emergency Overview)

Developer is a black powder containing small amounts of toner, and possessing no immediate hazard. There are no anticipated carcinogenic effects from exposure based on animal tests performed using toner.

Section 5.	Health Hazard Data
Route(s) of Entry:		Inhalation?	Skin?	Ingestion?
		No	No	Possible but very unusual.

Health Hazards: Acute oral toxicity ------------- LDL0 of this toner which is included in this developer

is over 2,000mg/kg.

Mutagenicity -------------------- The toner, which is included in this developer, has been

tested on Ames test. The result is negative.

Carcinogenicity: In 1996 the IARC reevaluated carbon black as a Group 2B carcinogen (possible human carcinogen). This classification is given to chemicals for which there is inadequate human evidence, but sufficient animal evidence on which to base an opinion of carcinogenicity. The classification is based upon the development of lung tumors in rats receiving chronic inhalation exposures to free carbon black at levels that induce particle overload of the lung. Studies performed in animal models other than rats did not show any association between carbon black and lung tumors. While there have been no studies to date using developer, a two-year cancer bioassay using a typical toner preparation containing carbon black (a small amount of toner is included in the developer mixture) demonstrated no association between toner exposure and tumor development in rats.

Signs and Symptoms of Exposure: Minimal irritation to respiratory tract may occur as with exposure

	to any non-toxic dust.
Medical Conditions Generally Aggravated by Exposure: None
Emergency and First Aid Procedures:
Inhalation;	Remove to fresh air. If effects occur, consult medical personnel.
Eye;	In case of contact, immediately flush eyes with water for 15 minutes.