American Dryer Corp MDG-50 installation manual Table of Contents

Page 5

Table of Contents

SECTION I
IMPORTANT INFORMATION		3
A. Receiving and Handling		3
B.	Safety Precautions	4
SECTION II
SPECIFICATIONS		6
A. Specifications		6
SECTION III
INSTALLATION PROCEDURES		8
A. Unpacking and Setting Up		8
B. Location Requirements		9
C. Dryer Enclosure Requirements		10
D. Fresh Air Supply		11
E.	Exhaust Requirements	12
F.	Electrical Information	18
G.	Gas Information	23
H. Preparation For Operation and Start-Up		27
I.	Preoperational Tests	28
J.	Preoperational Instructions	29
K. Shut Down Instructions		32
SECTION IV
SERVICE and PARTS INFORMATION		33
A. Service		33
B. Parts		33
SECTION V
WARRANTY INFORMATION		34
A. Returning Warranty Cards		34

Image 5

Contents MDG-50 Installation Manual Retain This Manual In a Safe Place For Future Reference For Your Safety Page Table of Contents Section Routine Maintenance Important Information SectionPersonal Injury or Fire could Result Safety PrecautionsPage Specifications SpecificationsSpecifications Unpacking and Setting UP Installation ProceduresLocation Requirements Dryer Enclosure Requirements Fresh AIR Supply Exhaust Requirements Single Dryer Venting Illus. B Multiple Dryer Common Venting ILLUS. D Importantventingreminders Electrical Requirements Electrical InformationMust be Provided Odfn Klwh Uhhq Important a Circuit Serving Each Dryer Must be Provided DG-50 GAS Injury and Improper Operation of the Dryer GAS InformationType of GAS Page Page Preparation for Operation and START-UP Preoperational Tests Preoperational Instructions Page OPL Models Shut Down Instructions Parts ServiceSection Returning Warranty CardsCleaning Routine MaintenanceLubrication AdjustmentsDrive motor not operating does not start TroubleshootingNo L.E.D. light emitting diode display Blower motor not operating does not start Microprocessor controller computer display reads door Microprocessor computer display reads dSFLNo heat, ignitor sparks, burner goes on and off right away Dryer operates but is taking too long to dry Dryer or scraping noise at basket tumbler area Condensation on main door glassDrive motor only not operating Excessive noise or vibrationMain burners are burning with a yellow flame Dryer operates but is taking too long to dry load Heating unit not operating ALL temperature selectionsBlower motor only not operating Dryer is cycling on hi-limit thermostat Data Label Technical InformationSerial Number Timing Legend Reversing Timer SPIN/DWELL AdjustmentsProcedure for Functional Check Replacement Components Direct Spark Ignition DSI System 10/30/00-150