Yamaha TT-R110EX owner manual Cleaning the air filter element, To clean the air filter element

Page 41

PERIODIC MAINTENANCE AND MINOR REPAIR

7.Turn the engine off, and then check the oil level and correct it if necessary.

EAU41633

Cleaning the air filter element

The air filter element should be cleaned at the intervals specified in the periodic maintenance and lubrication chart. Clean the air filter element more fre- quently if you are riding in unusually wet or dusty areas.

To clean the air filter element

1.Remove panel A. (See page 6-6.)

2.Remove the air filter case cover by removing the screws.

1

2

1.Air filter case cover

2.Screw

3.Pull the sponge material and the mesh out.

1

2

1.Sponge material

2.Air filter mesh

4.Clean the mesh with solvent, and then wipe the solvent off.

5.Clean the sponge material with

solvent, and then squeeze the re- 6 maining solvent out.

EWA10430

WARNING

Use only a dedicated parts cleaning solvent. To avoid the risk of fire or explosion, do not use gasoline or solvents with a low flash point.

ECA10510

CAUTION:

To avoid damaging the foam materi- al, handle it gently and carefully, and do not twist or wring it.

6-10

Image 41

Contents TT-R110EX EAU10041 Introduction AN Important Safety MessageIntroduction Involved Important Manual InformationEWA14460 Affix Dealer Label Here Table of Contents Motorcycle Care Safe riding Safety InformationProtective apparel ModificationsLoading and accessories Gasoline is Highly FLAMMA- BLE Gasoline and exhaust gasTire Infomation Location of important labelsLeft view DescriptionRight view Controls and instruments Instrument and Control Functions Main switchHandlebar switches Brake pedal Shift pedalBrake lever Avoid spilling fuel on the hot en- gine Fuel tank capGasohol Fuel tank breather hoseFuel cock RES Starter choke leverKickstarter To install the seatSeat To remove the seatStarting circuit cut-off system SidestandNo YES PRE-OPERATION Checks Checks Pre-operation check listBrake pedal Starting and warming up a cold engine Operation and Important Riding PointsTo start out and accelerate Starting a warm engineShifting To decelerate Engine break-inParking Maintenance, replacement, or repair Periodic Maintenance and Minor RepairEmission control devices That is certified if applicableOwner’s tool kit Initial Odometer Readings Checks and Maintenance Jobs Periodic maintenance chart for the emission control systemWheels General maintenance and lubrication chartBrake lever pivot shaft Panel B Removing and installing pan- elsPanel a To check the spark plug Checking the spark plugTo remove the spark plug To check the engine oil level To install the spark plugEngine oil To change the engine oil To clean the air filter element Cleaning the air filter elementInders may become excessively worn Cleaning the spark arrester Adjusting the engine idling speed Adjusting the carburetorValve clearance Checking the throttle cable free playTire air pressure TiresTire inspection Tire informationSpoke wheels Accessories and replacement partsAdjusting the brake lever free play Adjusting the clutch free playAdjusting the brake pedal free play Checking the front and rear brake shoes Checking the shift pedalFront RearTo check the drive chain slack To adjust the drive chain slackDrive chain slack Cleaning and lubricating the drive chain Checking and lubricating the throttle grip and cable Checking and lubricating the cablesChecking and lubricating Brake lever Brake pedal Sidestand Checking the front fork Lubricating the swingarm piv- otsTo check the condition To check the operationChecking the wheel bearings Checking the steeringTo store the battery BatteryTo charge the battery Replacing the fuse To service the rear wheel To service the front wheelSupporting the motorcycle Front wheelTo install the front wheel To remove the rear wheel Rear wheelTo install the rear wheel TroubleshootingBattery Troubleshooting chartCompression IgnitionCleaning Before cleaningMotorcycle Care and Storage Matte color cautionMake sure that there is no oil or wax on the tires After cleaningShort-term StorageEWA10950 Dimensions SpecificationsChassis Vehicle identification number Consumer InformationIdentification numbers Model label Tampering with Noise Control System Prohibited Motorcycle noise regulationProduct Excluded from Warranty Consumer Information Yamaha Extended Service Y.E.S Consumer Information Index Air filter element, cleaningPage Page Printed on Recycled Paper