Yamaha TT-R110EX owner manual To install the front wheel

Page 60

PERIODIC MAINTENANCE AND MINOR REPAIR

1.Axle nut

2.Washer

EAU41691

To install the front wheel

1.Lift the wheel up between the fork legs.

2.Insert the wheel axle from the right-hand side.

NOTE:

Make sure that the slot in the brake shoe plate fits over the retainer on the fork leg.

Tightening torque:

Axle nut:

35Nm (3.5 m·kgf, 25 ft·lbf)

5.Adjust the brake lever free play. (See page 6-17.)

6.While applying the front brake, push down hard on the handlebar several times to check for proper fork operation.

3.Lift the front wheel off the ground according to the procedure on

page 6-28.

64. Remove the axle nut and washer.

5.Pull the wheel axle out, and then remove the wheel.

2

1

1. Slot

2. Retainer

3. Lower the front wheel so that it is on the ground.

4. Install the washer and axle nut, and then tighten the axle nut to the specified torque.

1. Wheel axle

6-29

Image 60

Contents TT-R110EX EAU10041 AN Important Safety Message IntroductionIntroduction Important Manual Information InvolvedEWA14460 Affix Dealer Label Here Table of Contents Motorcycle Care Safety Information Safe ridingProtective apparel ModificationsLoading and accessories Gasoline and exhaust gas Gasoline is Highly FLAMMA- BLELocation of important labels Tire InfomationDescription Left viewRight view Controls and instruments Main switch Handlebar switchesInstrument and Control Functions Shift pedal Brake leverBrake pedal Fuel tank cap Avoid spilling fuel on the hot en- gineFuel tank breather hose Fuel cockGasohol Starter choke lever RESTo install the seat KickstarterSeat To remove the seatSidestand Starting circuit cut-off systemNo YES PRE-OPERATION Checks Pre-operation check list ChecksBrake pedal Operation and Important Riding Points Starting and warming up a cold engineStarting a warm engine ShiftingTo start out and accelerate Engine break-in To decelerateParking Periodic Maintenance and Minor Repair Maintenance, replacement, or repairEmission control devices That is certified if applicableOwner’s tool kit Periodic maintenance chart for the emission control system Initial Odometer Readings Checks and Maintenance JobsGeneral maintenance and lubrication chart WheelsBrake lever pivot shaft Removing and installing pan- els Panel aPanel B Checking the spark plug To remove the spark plugTo check the spark plug To install the spark plug Engine oilTo check the engine oil level To change the engine oil Cleaning the air filter element To clean the air filter elementInders may become excessively worn Cleaning the spark arrester Adjusting the carburetor Adjusting the engine idling speedChecking the throttle cable free play Valve clearanceTires Tire air pressureTire inspection Tire informationAccessories and replacement parts Spoke wheelsAdjusting the clutch free play Adjusting the brake lever free playAdjusting the brake pedal free play Checking the shift pedal Checking the front and rear brake shoesFront RearTo adjust the drive chain slack Drive chain slackTo check the drive chain slack Cleaning and lubricating the drive chain Checking and lubricating the cables Checking and lubricating the throttle grip and cableChecking and lubricating Brake lever Brake pedal Sidestand Lubricating the swingarm piv- ots Checking the front forkTo check the condition To check the operationChecking the steering Checking the wheel bearings Battery To charge the battery To store the battery Replacing the fuse To service the front wheel To service the rear wheelSupporting the motorcycle Front wheelTo install the front wheel Rear wheel To remove the rear wheelTroubleshooting To install the rear wheelTroubleshooting chart BatteryCompression IgnitionBefore cleaning CleaningMotorcycle Care and Storage Matte color cautionAfter cleaning Make sure that there is no oil or wax on the tiresStorage Short-termEWA10950 Specifications DimensionsChassis Consumer Information Identification numbersVehicle identification number Model label Motorcycle noise regulation Tampering with Noise Control System ProhibitedProduct Excluded from Warranty Consumer Information Yamaha Extended Service Y.E.S Consumer Information Air filter element, cleaning IndexPage Page Printed on Recycled Paper