Yamaha TT-R110EX owner manual Replacing the fuse

Page 58

PERIODIC MAINTENANCE AND MINOR REPAIR

charger will damage the battery. If you do not have access to a sealed-type (MF) battery charg- er, have a Yamaha dealer charge your battery.

6

EAU42021

Replacing the fuse

2

1

1.Fuse

2.Spare fuse

The fuse is located inside the battery coupler. (See page 6-26.)

If the fuse is blown, replace it as fol- lows.

1.Turn the key to “OFF” and turn off all electrical circuits.

2.Disconnect the battery coupler.

3.Remove the blown fuse, and then install a new fuse of the specified amperage.

Specified fuse:

10.0 A

ECA10640

CAUTION:

Do not use a fuse of a higher amper- age rating than recommended to avoid causing extensive damage to the electrical system and possibly a fire.

4.Connect the battery coupler.

5.Turn the key to “ON” and turn on the electrical circuits to check if the devices operate.

6.If the fuse immediately blows again, have a Yamaha dealer check the electrical system.

6-27

Image 58

Contents TT-R110EX EAU10041 AN Important Safety Message IntroductionIntroduction Important Manual Information InvolvedEWA14460 Affix Dealer Label Here Table of Contents Motorcycle Care Protective apparel Safety InformationSafe riding ModificationsLoading and accessories Gasoline and exhaust gas Gasoline is Highly FLAMMA- BLELocation of important labels Tire InfomationDescription Left viewRight view Controls and instruments Handlebar switches Main switchInstrument and Control Functions Brake lever Shift pedalBrake pedal Fuel tank cap Avoid spilling fuel on the hot en- gineFuel cock Fuel tank breather hoseGasohol Starter choke lever RESSeat To install the seatKickstarter To remove the seatSidestand Starting circuit cut-off systemNo YES PRE-OPERATION Checks Pre-operation check list ChecksBrake pedal Operation and Important Riding Points Starting and warming up a cold engineShifting Starting a warm engineTo start out and accelerate Engine break-in To decelerateParking Emission control devices Periodic Maintenance and Minor RepairMaintenance, replacement, or repair That is certified if applicableOwner’s tool kit Periodic maintenance chart for the emission control system Initial Odometer Readings Checks and Maintenance JobsGeneral maintenance and lubrication chart WheelsBrake lever pivot shaft Panel a Removing and installing pan- elsPanel B To remove the spark plug Checking the spark plugTo check the spark plug Engine oil To install the spark plugTo check the engine oil level To change the engine oil Cleaning the air filter element To clean the air filter elementInders may become excessively worn Cleaning the spark arrester Adjusting the carburetor Adjusting the engine idling speedChecking the throttle cable free play Valve clearanceTire inspection TiresTire air pressure Tire informationAccessories and replacement parts Spoke wheelsAdjusting the clutch free play Adjusting the brake lever free playAdjusting the brake pedal free play Front Checking the shift pedalChecking the front and rear brake shoes RearDrive chain slack To adjust the drive chain slackTo check the drive chain slack Cleaning and lubricating the drive chain Checking and lubricating the cables Checking and lubricating the throttle grip and cableChecking and lubricating Brake lever Brake pedal Sidestand To check the condition Lubricating the swingarm piv- otsChecking the front fork To check the operationChecking the steering Checking the wheel bearingsTo charge the battery BatteryTo store the battery Replacing the fuse Supporting the motorcycle To service the front wheelTo service the rear wheel Front wheelTo install the front wheel Rear wheel To remove the rear wheelTroubleshooting To install the rear wheelCompression Troubleshooting chartBattery IgnitionMotorcycle Care and Storage Before cleaningCleaning Matte color cautionAfter cleaning Make sure that there is no oil or wax on the tiresStorage Short-termEWA10950 Specifications DimensionsChassis Identification numbers Consumer InformationVehicle identification number Model label Motorcycle noise regulation Tampering with Noise Control System ProhibitedProduct Excluded from Warranty Consumer Information Yamaha Extended Service Y.E.S Consumer Information Air filter element, cleaning IndexPage Page Printed on Recycled Paper