Yamaha TT-R110EX owner manual Checking the throttle cable free play, Valve clearance

Page 45

PERIODIC MAINTENANCE AND MINOR REPAIR

rection (a). To decrease the en- gine idling speed, turn the screw in direction (b).

(a) (b)

EAU21382

Checking the throttle cable free play

EAU21401

Valve clearance

The valve clearance changes with use, resulting in improper air-fuel mixture and/or engine noise. To prevent this from occurring, the valve clearance must be adjusted by a Yamaha dealer

1

1

1.Throttle stop screw

Engine idling speed:

1600–1800 r/min

NOTE:

If the specified idling speed cannot be obtained as described above, have a Yamaha dealer make the adjustment.

1

1. Throttle cable free play

The throttle cable free play should mea- sure 4.0–6.0 mm (0.16–0.24 in) at the throttle grip. Periodically check the throttle cable free play and, if neces- sary, have a Yamaha dealer adjust it.

at the intervals specified in the periodic maintenance and lubrication chart.

6

6-14

Image 45

Contents TT-R110EX EAU10041 Introduction AN Important Safety MessageIntroduction Involved Important Manual InformationEWA14460 Affix Dealer Label Here Table of Contents Motorcycle Care Safe riding Safety InformationProtective apparel ModificationsLoading and accessories Gasoline is Highly FLAMMA- BLE Gasoline and exhaust gasTire Infomation Location of important labelsLeft view DescriptionRight view Controls and instruments Main switch Handlebar switchesInstrument and Control Functions Shift pedal Brake leverBrake pedal Avoid spilling fuel on the hot en- gine Fuel tank capFuel tank breather hose Fuel cockGasohol RES Starter choke leverKickstarter To install the seatSeat To remove the seatStarting circuit cut-off system SidestandNo YES PRE-OPERATION Checks Checks Pre-operation check listBrake pedal Starting and warming up a cold engine Operation and Important Riding PointsStarting a warm engine ShiftingTo start out and accelerate To decelerate Engine break-inParking Maintenance, replacement, or repair Periodic Maintenance and Minor RepairEmission control devices That is certified if applicableOwner’s tool kit Initial Odometer Readings Checks and Maintenance Jobs Periodic maintenance chart for the emission control systemWheels General maintenance and lubrication chartBrake lever pivot shaft Removing and installing pan- els Panel aPanel B Checking the spark plug To remove the spark plugTo check the spark plug To install the spark plug Engine oilTo check the engine oil level To change the engine oil To clean the air filter element Cleaning the air filter elementInders may become excessively worn Cleaning the spark arrester Adjusting the engine idling speed Adjusting the carburetorValve clearance Checking the throttle cable free playTire air pressure TiresTire inspection Tire informationSpoke wheels Accessories and replacement partsAdjusting the brake lever free play Adjusting the clutch free playAdjusting the brake pedal free play Checking the front and rear brake shoes Checking the shift pedalFront RearTo adjust the drive chain slack Drive chain slackTo check the drive chain slack Cleaning and lubricating the drive chain Checking and lubricating the throttle grip and cable Checking and lubricating the cablesChecking and lubricating Brake lever Brake pedal Sidestand Checking the front fork Lubricating the swingarm piv- otsTo check the condition To check the operationChecking the wheel bearings Checking the steeringBattery To charge the batteryTo store the battery Replacing the fuse To service the rear wheel To service the front wheelSupporting the motorcycle Front wheelTo install the front wheel To remove the rear wheel Rear wheelTo install the rear wheel TroubleshootingBattery Troubleshooting chartCompression IgnitionCleaning Before cleaningMotorcycle Care and Storage Matte color cautionMake sure that there is no oil or wax on the tires After cleaningShort-term StorageEWA10950 Dimensions SpecificationsChassis Consumer Information Identification numbersVehicle identification number Model label Tampering with Noise Control System Prohibited Motorcycle noise regulationProduct Excluded from Warranty Consumer Information Yamaha Extended Service Y.E.S Consumer Information Index Air filter element, cleaningPage Page Printed on Recycled Paper