Yamaha TT-R110EX Motorcycle Care and Storage, Matte color caution, Before cleaning, Cleaning

Page 64

MOTORCYCLE CARE AND STORAGE

EAU37833

Matte color caution

ECA15192

CAUTION:

Some models are equipped with matte colored finished parts. Be sure to consult a Yamaha dealer for advice on what products to use be- fore cleaning the vehicle. Using a brush, harsh chemical products or cleaning compounds when cleaning these parts will scratch or damage their surface. Wax also should not be applied to any matte colored fin- ished parts.

7

EAU40462

Care

While the open design of a motorcycle reveals the attractiveness of the tech- nology, it also makes it more vulnera- ble. Rust and corrosion can develop even if high-quality components are used. A rusty exhaust pipe may go un- noticed on a car, however, it detracts from the overall appearance of a motor- cycle. Frequent and proper care does not only comply with the terms of the warranty, but it will also keep your motorcycle looking good, extend its life and optimize its performance.

Before cleaning

1.Cover the muffler outlet with a plastic bag after the engine has cooled down.

2.Make sure that all caps and covers as well as all electrical couplers and connectors, including the spark plug cap, are tightly in- stalled.

3.Remove extremely stubborn dirt, like oil burnt onto the crankcase, with a degreasing agent and a brush, but never apply such prod-

7-1

ucts onto seals, gaskets, sprock- ets, the drive chain and wheel axles. Always rinse the dirt and de- greaser off with water.

Cleaning

ECA10771

CAUTION:

●Avoid using strong acidic wheel cleaners, especially on spoked wheels. If such products are used on hard-to-remove dirt, do not leave the cleaner on the af- fected area any longer than in- structed. Also, thoroughly rinse the area off with water, immedi- ately dry it, and then apply a cor- rosion protection spray.

●Improper cleaning can damage plastic parts such as cowlings, panels, windshields, headlight lenses, meter lenses, etc. Use only a soft, clean cloth or sponge with mild detergent and water to clean plastic.

●Do not use any harsh chemical products on plastic parts. Be sure to avoid using cloths or sponges which have been in

Image 64

Contents TT-R110EX EAU10041 AN Important Safety Message IntroductionIntroduction Important Manual Information InvolvedEWA14460 Affix Dealer Label Here Table of Contents Motorcycle Care Safety Information Safe ridingProtective apparel ModificationsLoading and accessories Gasoline and exhaust gas Gasoline is Highly FLAMMA- BLELocation of important labels Tire InfomationDescription Left viewRight view Controls and instruments Handlebar switches Main switchInstrument and Control Functions Brake lever Shift pedalBrake pedal Fuel tank cap Avoid spilling fuel on the hot en- gineFuel cock Fuel tank breather hoseGasohol Starter choke lever RESTo install the seat KickstarterSeat To remove the seatSidestand Starting circuit cut-off systemNo YES PRE-OPERATION Checks Pre-operation check list ChecksBrake pedal Operation and Important Riding Points Starting and warming up a cold engineShifting Starting a warm engineTo start out and accelerate Engine break-in To decelerateParking Periodic Maintenance and Minor Repair Maintenance, replacement, or repairEmission control devices That is certified if applicableOwner’s tool kit Periodic maintenance chart for the emission control system Initial Odometer Readings Checks and Maintenance JobsGeneral maintenance and lubrication chart WheelsBrake lever pivot shaft Panel a Removing and installing pan- elsPanel B To remove the spark plug Checking the spark plugTo check the spark plug Engine oil To install the spark plugTo check the engine oil level To change the engine oil Cleaning the air filter element To clean the air filter elementInders may become excessively worn Cleaning the spark arrester Adjusting the carburetor Adjusting the engine idling speedChecking the throttle cable free play Valve clearanceTires Tire air pressureTire inspection Tire informationAccessories and replacement parts Spoke wheelsAdjusting the clutch free play Adjusting the brake lever free playAdjusting the brake pedal free play Checking the shift pedal Checking the front and rear brake shoesFront RearDrive chain slack To adjust the drive chain slackTo check the drive chain slack Cleaning and lubricating the drive chain Checking and lubricating the cables Checking and lubricating the throttle grip and cableChecking and lubricating Brake lever Brake pedal Sidestand Lubricating the swingarm piv- ots Checking the front forkTo check the condition To check the operationChecking the steering Checking the wheel bearingsTo charge the battery BatteryTo store the battery Replacing the fuse To service the front wheel To service the rear wheelSupporting the motorcycle Front wheelTo install the front wheel Rear wheel To remove the rear wheelTroubleshooting To install the rear wheelTroubleshooting chart BatteryCompression IgnitionBefore cleaning CleaningMotorcycle Care and Storage Matte color cautionAfter cleaning Make sure that there is no oil or wax on the tiresStorage Short-termEWA10950 Specifications DimensionsChassis Identification numbers Consumer InformationVehicle identification number Model label Motorcycle noise regulation Tampering with Noise Control System ProhibitedProduct Excluded from Warranty Consumer Information Yamaha Extended Service Y.E.S Consumer Information Air filter element, cleaning IndexPage Page Printed on Recycled Paper