Vermont Casting VCS3008 Series, VCS5008BI, VCS5008 Series Signal Words, Important Warnings

Page 3

Warnings

This Gas Barbecue Grill will provide you with many hours of pleasure and enjoyment, if it is used in accor- dance with the Warnings and Operating Instructions contained in this Manual.

Always comply with all of the Warnings and Operating Instructions contained in this manual to pre- vent personal injury or property damage.

SIGNAL WORDS:

The Signal Words used in this Manual, and their intended meanings, are as follows :

DANGER: Indicates that a failure to observe the safety instructions could result in death or catastrophic bodily injury.

WARNING: Indicates that a failure to observe the safety instructions could result in serious bodily injury.

CAUTION: Indicates that a failure to observe the safety instructions could result in property damage or minor bodily injury.

NOTICE: Designates important information relating to the safe use of the Grill.

IMPORTANT WARNINGS:

Since this outdoor cooking appliance is movable, is fueled by natural or propane gas, generates very high tem- peratures for cooking and emits carbon monoxide as a by-product of combustion, prudent precautions must be taken to assure its safe use.

DANGER

• This Grill has been designed for OUTDOOR use only.

Never use this outdoor Grill inside any building, garage, shed, breezeway, or any other enclosed area, to prevent a possible fire and to prevent the possibility of carbon monoxide poisoning or asphyxiation.

This outdoor cooking gas appliance is not intended to be installed in or on boats (any vessels). This outdoor cooking gas appliance is not intended to be installed in or on recreational vehicles.

•Exposing an overfilled or a disconnected propane cylinder to heat could cause venting of fuel through the pressure release valve. Since propane vapor is heavier than air it tends to pool and, if ignited, could produce a violent fire or explosion.

Never install a propane cylinder in this grill if it is more than 80% full, as the contents may lack adequate room for expansion when exposed to heat.

Never store a spare Propane Gas Cylinder in the cylinder-compartment of this Grill, because it will be exposed to high temperatures when the Grill is in use.

The essential Warnings and Safety Instructions are located throughout the pages of this Manual, but some of the principal ones have been summarized as follows for your convenience:

Page ii

50004581

Page 2 Page 4
Image 3
Page 2 Page 4
Contents USER’S Manual Model VCS5008 Parts IdentificationImportant Warnings Signal WordsSafe Locations for USE of this Outdoor Grill B149.1, Natural Gas and Propane Installation CodeSafe USE of Natural NG GAS Safe USE of Propane LP GASSafety Safe USE of Natural NG GASPrevention of Burns Battery Handling Electrical SafetyTable of Contents Propane GAS Fuel Always keep cylinders out of reach of children Propane GAS FuelConnecting the Grill to a Propane LP GAS Cylinder Gas HookupHooking Up to the Propane LP Gas Supply To Disconnect Connecting the Grill to the Main GAS SupplyHooking Up the Grill to the Natural NG Gas Supply To ConnectBurner Control Valves Fig OperationControl Functions Propane Tank ValveClear and then repeat the preceding Lighting the Main BurnersErs, to avoid exposure to possible flare-ups If the Selected Burner does not LightTurning the Burners Off FLARE-UPSMatch Lighting the Main Burners Grill Lighting the Rotisserie Burner if applicableTo Start the Rotisserie Burner Match Lighting the Rotisserie BurnerRotisserie Setup if equipped Rotisserie Setup Lighting the Side Burner if applicableShutting the Burner OFF Cooking Methods of CookingHard boiling soups, lobsters or corn on the cob. c Preparing Food for the Grill Grilling Tips Type of Food Weight Cooking Cooking Time Cooking Time ChartType of Food Weight Type of Food Care & Cleaning Care & MaintenanceRotisserie Burner if applicable Side Burner if applicableCooking Grids Drip Tray Stainless Steel PanelsPorcelain Enamel Castings Burner Adjustment MaintenanceProblem Potential Cause Action Required Troubleshooting GuideTroubleshooting Guide Cast Iron Cooking Grates Side Burner All Remaining Parts Limited Lifetime WarrantyYear Warranty Porcelain Coated Firebox and Rear Lid Assembly
Top Page Image Contents