Craftsman 919.724701 owner manual Pressure reading

Page 22

PROBLEM	CAUSE	CORRECTION
Pressure reading	It is normal for "some"	If there is an excessive
on the regulated	pressure drop to occur.	amount of pressure drop
pressure gauge		when the accessory is used,
drops when an		adjust the regulator following
accessory is		the instructions in the
used.		"Description of Operation"
		paragraph in the “Operation
		Section.
		NOTE: Adjust the regulated
		pressure under flow
		conditions (while accessory
		is being used).
Knocking Noise.	Possible defect in safety	Operate safety valve
	valve.	manually by pulling on ring.
		If valve still leaks, it should
		be replaced.
	Defective check valve.	Remove and clean, or
		replace.

Compressor is	Prolonged excessive use of	Decrease amount of air
not supplying	air.	usage.
enough air to	Compressor is not large	Check the accessory air
operate	Compressor is not large	Check the accessory air
accessories.	enough for air requirement.	requirement. If it is higher
		than the SCFM or pressure
		supplied by your air
		compressor, you need a
		larger compressor.
	Hole in hose.	Check and replace if
		required.
	Check valve restricted.	Remove and clean, or
		replace.
	Air leaks.	Tighten fittings.
	Restricted air intake filter.	Clean or replace air intake
		filter. Do not operate the air
		compressor with the filter
		removed. Refer to the "Air
		Filter" paragraph in the
		"Maintenance" section.

Regulator knob	Damaged regulator.	Replace.
has continuous
air leak.

D27610

22- ENG

Image 22

Contents AIR Compressor Sold by Sears Canada, Inc. Toronto, Ont. M5B 2B8Table of Contents Safety Guidelines Definitions Specification ChartImportant Safety Instructions Hazard What Could HappenWhat can Happen Hazard Never operate the compressor with Result in serious burnsBelt can cause serious injury if they When Transporting Compressor Glossary AccessoriesAccessories Duty CycleAssembly Location of the Air Compressor InstallationPlug Grounded Outlets Grounding Pin Extension Cords Voltage and Circuit ProtectionOutlet Pressure Gauge The outlet OperationDescription of Operation Tank Pressure Gauge The tankHow to Use Your Unit Break-in ProcedureHow to Start Customer Responsibilities MaintenanceTo Check Safety Valve To Drain TankMotor Air Filter Inspection and ReplacementAir Compressor Pump Intake and Exhaust Valves Air FilterRing Service and AdjustmentsTo Replace or Clean Check Valve Nut Outlet Tube Pressure Relief Check ValveRegulator Tank Outlet Pressure PressureGauge Quick Connect To Replace RegulatorRegulator Arrow Storage Troubleshooting Pressure reading Check wiring connection Table DES Matières Sears Canada, Inc., Toronto, Ont. M5B 2B8Mesures DE Sécurité Définitions Tableau DES SpécificationsConsignes DE Sécurité Importantes Conserver ces directives Avertissement Risque dexplosion ou dincendie PréventionRisque Prévention Avertissement Risque déclatementAvertissement Risque de projection dobjets Avertissement Risque de choc électrique Avertissement Risque par inhalationAvertissement Risque relié aux pièces mobiles Avertissement Risque de brûluresAvertissement Risque de chute Risque Avertissement Risque dune utilisation dangereuseAccessoires AccessoiresCycle DE Service LexiqueAssemblage Emplacement du compresseur dair Terre inappropriée peut entraîner des chocs électriquesRallonges Protection contre la surtension et protection du circuitFamiliarisez-vous avec votre compresseur dair UtilisationDescription du fonctionnement Arrêt de lappareil Utilisation de lappareilAvant le démarrage Procédures de rodageAvant chaque mise en marche Mise en marcheVérification de la soupape de sûreté EntretienResponsabilités du client Vidange du réservoirRisque de brûlures Filtre à air Inspection et remplacementMoteur Filtre à airRemplacement ou nettoyage de la soupape de retenue Entretien ET RéglagesRemplacement du régulateur Régulateur FlècheRangement Risque déclatementDéclatement.Ne pas percer DépannageSerrer ExploserConsidérée normale Pas Surcharges déclenché 54- FR 55- FR D27610 Get it fixed, at your home or ours