Craftsman 919.7243 owner manual Troubleshooting

Page 21

TROUBLESHOOTING

Risk of Unsafe Operation. Unit cycles automatically when power is on. When servicing, you may be exposed to

voltage sources, compressed air, or moving parts. Before servicing unit unplug or disconnect electrical supply to the air compressor, bleed tank of pressure, and allow the air compressor to cool.

PROBLEM	CAUSE		CORRECTION
Excessive tank	Pressure switch does not	Move On/Auto/Off lever to
pressure - safety	shut off motor when	the "OFF" position, if the
valve pops off.	compressor reaches	outfit does not shut off
	"cut-out" pressure.	contact a Trained Service
		Technician.
	Pressure switch "cut-out"	Contact a Trained Service
	too high.	Technician.

Air leaks at	Tube fittings are not tight	Tighten fittings where air can
fittings.	enough.	be heard escaping. Check
		fittings with soapy water
		solution. Do Not
		Overtighten.
Air leaks at or	Check valve seat damaged.	A defective check valve
inside check		results in a constant air leak
valve.		at the pressure release valve
		when there is pressure in the
		tank and the compressor is
		shut off. Replace check
		valve. Refer to the "To
		Replace or Clean Check
		Valve" in the "Service and
		Adjustment" section.

Air leaks at	Defective pressure switch	Contact a Trained Service
pressure switch	release valve.	Technician.
release valve.

Air leaks in air	Defective air tank.	Air tank must be replaced.
tank or at air		Do not repair the leak.
tank welds.						Risk of


						Bursting.
						Bursting.
		Do not drill into, weld or
		otherwise modify air tank
		or it will weaken. The tank
		can rupture or explode.

Air leaks	Leaking seal.	Contact a Trained Service
between head		Technician.
and valve plate.

21- ENG

D26700

Image 21

Contents Sold by Sears Canada, Inc. Toronto, Ont. M5B 2B8 AIR CompressorTable of Contents Specification Chart Safety Guidelines DefinitionsImportant Safety Instructions Explosion May be required Spray area. An additional length of hoseLocation away from compressor Fire, do not allow the compressor toAttachments & Accessories Repairs attempted by unqualified Safety equipment must be properlyAccordance with national and local Electrical codesResult in serious burns Or attempt maintenance until unit hasHot for several minutes after operation Do not reach around protective shroudsFire, Inhalation, Damage to Vehicle Surfaces Accessories AccessoriesGlossary Duty CycleContents of Carton AssemblyTools Required for Assembly Assemble Wheels UnpackingInstallation Location of the Air CompressorPlug Grounded Outlets Grounding Pin Voltage and Circuit Protection Extension CordsOperation Know Your Air CompressorDescription of Operation Before First Start-up How to StopHose Wrap Conveniently stores up to 50 feet of air hose Hose WrapBefore Each Start-Up How to StartTo Check Safety Valve MaintenanceCustomer Responsibilities To Drain TankAir Filter Inspection Replacement Air Compressor Pump Intake and Exhaust ValvesAir Filter To Replace or Clean Check Valve Service and AdjustmentsNut Outlet Tube Pressure Relief Check Valve Screwdriver Open position nothing is visibleOutlet Pressure Gauge Regulator Quick Connect To Replace RegulatorNipple Regulator ArrowStorage Troubleshooting Pressure reading Check wiring connection Sears Canada, Inc., Toronto, Ont. M5B 2B8 Table DES MatièresTableau DES Spécifications Mesures DE Sécurité DéfinitionsConsignes DE Sécurité Importantes Avertissement Risque dexplosion ou dincendie Prévention Conserver ces directivesAvertissement Risque déclatement Risque PréventionAvertissement Risque de projection dobjets Avertissement Risque par inhalation Avertissement Risque de choc électriqueAvertissement Risque de brûlures Avertissement Risque relié aux pièces mobilesAvertissement Risque de chute Avertissement Risque dune utilisation dangereuse RisqueCycle DE Service AccessoiresAccessoires LexiqueAssemblage Terre inappropriée peut entraîner des chocs électriques Emplacement du compresseur dairProtection contre la surtension et protection du circuit RallongesUtilisation Familiarisez-vous avec votre compresseur dairDescription du fonctionnement Arrêt de lappareil Utilisation de lappareilAvant le démarrage Dévidoir PourMise en marche Avant chaque mise en marcheResponsabilités du client EntretienVérification de la soupape de sûreté Vidange du réservoirFiltre à air Filtre à air Inspection et remplacementEntretien ET Réglages Remplacement ou nettoyage de la Soupape de retenueRégulateur Raccord à connexion rapide Remplacement du régulateurEmbout RégulateurRangement Serrer DépannageDéclatement. Ne pas percer ExploserConsidérée normale Pas Surcharges déclenché 54- FR 55- FR D26700 Get it fixed, at your home or ours