Husky D29616 manual Maintenance, Customer Responsibilities, To Check Safety Valve, To Drain Tank

Page 14

MAINTENANCE

Customer Responsibilities

	Before	Daily or
	each	after
	each	each
	use	each
	use	use
		use
Check Safety Valve	●
Drain Tank		●

Unit cycles automatically when power is on. When performing maintenance, you may be exposed to voltage

sources, compressed air, or moving parts. Personal injuries can occur. Before performing any maintenance or repair, disconnect power source from the compressor and bleed off all air pressure.

NOTE: See "Operation" section for the location of controls.

To Check Safety Valve

If the safety valve does not work properly, over- pressurization may occur, causing air tank rupture or an explosion.

1.Before starting compressor, pull the ring on the safety valve to make sure that the safety valve operates freely. If the valve is stuck or does not operate smoothly, it must be replaced with the same type of valve.

To Drain Tank

1.Set the On/Auto/Off switch to "OFF" and unplug unit.

2.Pull the regulator knob out and turn counter-clockwise to set the outlet pressure to zero.

3.Remove the air tool or accessory.

4.Pull ring on safety valve allowing air to bleed from the tank until tank pressure is approximately 20 psi. Release safety valve ring.

5.Drain water from air tank by opening drain valve (counter-clockwise) on bottom of tank.

Water will condense in the air tank. If not drained, water will corrode and weaken the air tank causing a risk of air

tank rupture.

6.After the water has been drained, close the drain valve (clockwise). The air compressor can now be stored.

NOTE: If drain valve is plugged, release all air pressure. The valve can then be removed, cleaned, the reinstalled.

D29616

14- ENG

Image 14

Contents Air Compressor Operator’s Manual Or serious injury Minor or moderate injury Safety Guidelines DefinitionsImportant Safety Instructions Death or serious injuryLocation away from compressor Spray area. An additional length of hoseExplosion May be required Fire, do not allow the compressor toAttachments & Accessories What Could HappenRepairs attempted by unqualified Safety equipment must be properlyElectricity. Like any other electrically Air to all applicable local and federalHot for several minutes after operation Or attempt maintenance until unit hasResult in serious burns Do not reach around protective shroudsFire, Inhalation, Damage to Vehicle Surfaces Duty Cycle SpecificationsGlossary Model No Y6020Plug InstallationLocation of the Air Compressor OutletsExtension Cords Voltage and Circuit ProtectionDescription of Operation OperationKnow Your Air Compressor Before Starting How to StopAccessory Storage Cooling System not shown This compressorHow to Start Before Each Start-UpCustomer Responsibilities MaintenanceTo Check Safety Valve To Drain TankService and Adjustments StorageTroubleshooting Pressure reading Problem Cause Correction Limited Warranty Husky Air Compressor warranted by DapcModeradas Definiciones DE Normas DE SeguridadMuerte o lesiones serias Lesiones serias Causar daños en la propiedadInstrucciones Importantes DE Seguridad Cómo prevenirloAdvertencia Riesgo de Explosión Qué puede occurrir Cómo prevenirloNunca opere el compresor sin sus defensas o Advertencia Riesgo de Quemaduras Qué puede occurrir Advertencia Riesgo de Caída Qué puede occurrirAdvertencia Riesgo de Operación Lasegura Qué puede occurrir Modelo No Y6020 GlosarioCiclo DE Servicio Plug Grounding Pin Grounded Outlets InstalaciónUbicación del compresor de aire Condiciones Cables de extensión eléctricaProtección del voltaje y del circuito Descripción de operaciones OperaciónConozca su compresor de aire Antes de poner en marcha Cómo utilizar su unidadCómo detenerla Antes de cada puesta en marcha Cómo poner en marchaCómo verificar la válvula de seguridad MantenimientoResponsabilidades del cliente Cómo drenar el tanqueAire, originando un riesgo de ruptura de sus paredes Servicio Y AjustesAlmacenaje Aire, ello lo debilitará. El Guía DE Diagnóstico DE ProblemasSobre la soldadura o cosa Tanque podría romperse oDesciende cuando El motor no funciona Garantía Limitada El compresor de aire Husky está garantizado por DapcOu la mort Causer des blessures mineures ou Moyennes Mesures DE Sécurité DéfinitionsConsignes DE Sécurité Importantes Évité, peut causer des dommages à laConserver ces directives Avertissement Risque dexplosion ou dincendie PréventionAvertissement Risque de projection dobjets Avertissement Risque déclatementRisque Prévention Avertissement Risque de choc électrique Avertissement Risque par inhalationAvertissement Risque de chute Avertissement Risque de brûluresAvertissement Risque relié aux pièces mobiles Risque Avertissement Risque dune utilisation dangereuseSpécifications Cycle DE ServiceLexique No de modèle Y6020Prises de courant mises à la terre Emplacement du compresseur dairFiche Rallonges Protection contre la surtension et protection du circuitDescription du fonctionnement UtilisationFamiliarisez-vous avec votre compresseur dair Régulateur Manomètre Du réservoir De sortieAvant le démarrage Utilisation de lappareilArrêt de lappareil Avant chaque mise en marche Mise en marcheVérification de la soupape de sûreté EntretienResponsabilités du client Vidange du réservoirEntretien ET Réglages RangementPeut éclater ou exploser DépannageSerrer Considérée normale Fusible sauté ou coupe-circuit 55- FR D29616 Garantie Limitée Le compresseur dair Husky est garanti par Dapc