Graco 16W889, 16W884 Digital Tracking System, ProContractor and Ironman units Operation Main Menu

Page 17

Digital Tracking System

(ProContractor and Ironman units)

Operation Main Menu

Short press to move to next display. Press and hold (5 seconds) to change units or reset data.

ti22713a

1.Turn pressure to lowest setting. Trigger gun to relieve pressure. Turn prime valve down to DRAIN position.

ti22714a ti13243a

2.Turn power ON. Pressure display appears. Dashes will not appear unless pressure is less than 200 psi (14 bar, 1,4 MPa).

OFF

ON

ti22715a

Change Display Units

Press and hold DTS button for 5 seconds to change pressure units (psi, bar, MPa) to desired units. Selec- tion of bar or MPa changes gallons to liters x 10. To change display units DTS must be in pressure display mode and pressure must be at zero.

FT

M

ti22716a

Digital Tracking System (ProContractor and Ironman units)

Job Gallons

1.Short press DTS button to move to Job Gallons (or liters x 10).

ti22717a

NOTE: JOB scrolls past, then the number of gallons sprayed above 1000 psi (70 bar, 7 MPa) displays.

Lifetime Gallons

1.Short press DTS button to move to Lifetime Gallons (or liters x 10).

NOTE: LIFE scrolls briefly, then the number of gal- lons sprayed above 1000 psi (70 bar, 7 MPa) dis- plays.

ti22718a

332919C

17

Image 17

Contents Operation Table of Contents Fire and Explosion Hazard Equipment Misuse Hazard Standard Models 3400, 3900, 5900, 5900HD, 7900, 7900HD Component IdentificationProContractor Models 3900, 5900, 7900, 5900HD, 7900HD Ironman Models 5900, 7900, 7900HD Lo-Boy Models 3900, 5900 Convertible Models Pressure Relief Procedure Grounding Setup Change Engine to Motor Convertible Models OnlyStartup Spray Switch Tip Guard AssemblyProContractor and Ironman units only Clearing Tip ClogsWatchDog Protection System ProContractor units only Hose ReelProContractor and Ironman units Operation Main Menu Digital Tracking SystemChange Display Units Job GallonsPress and hold DTS button to clear error code to zero Cleanup Turn prime valve down Drain position Pressure Relief Procedure MaintenanceProblem Cause Solution TroubleshootingTroubleshooting Fluid Pump Runs Constantly Troubleshooting ProcedureControl Board Malfunction Volts Control Board Malfunction StepsConvertible Electric Motor Will Not Run Convertible Electric Motor Will Not Run Steps See step Is there over 10-20 AC volts? Beep Two blinks is the same as E=02 Digital Display MessagesPinion Assembly/Clutch Armature Removal Pinion Assembly/Clutch Armature/ClampInstallation Metric Technical DataModels Models Honda GX160 Engine Ansi Power Rating @ 3600 rpm Horsepower Honda GX200 Engine Ansi Power Rating @ 3600 rpm Horsepower Graco Information Graco Standard Warranty