Graco 16W883, ti23055a, 16W884, 16W881, 16W867, 16W887, 16W984, 16W873, 16W871, 16W882, 16W987 Startup

Page 13

Startup

1.Place suction tube and drain tube in grounded metal pail partially filled with flushing fluid. Attach ground wire to pail and to earth ground.

ti14844a

2.Turn prime valve down to DRAIN position. Turn pressure control counterclockwise to lowest pres- sure.

ti14842a

ti22708a

3. Set pump switch OFF.

ti5790a

4.Start Engine

a. Move fuel valve to open.

ti5248a

b. Move choke to closed.

ti5249a

Startup

c.Set throttle to fast.

ti5250a

d. Set engine switch to ON.

ti5262a

5. Pull rope to start engine.

ti5263a

6.Increase pressure enough to start pump stroking and allow fluid to circulate for 15 seconds; turn pres- sure down and turn prime valve forward to SPRAY position.

ti22709a

ti14845a

7. Disengage spray gun trigger lock.

ti22818a

332919C

13

Image 13

Contents Operation Table of Contents Fire and Explosion Hazard Equipment Misuse Hazard Standard Models 3400, 3900, 5900, 5900HD, 7900, 7900HD Component IdentificationProContractor Models 3900, 5900, 7900, 5900HD, 7900HD Ironman Models 5900, 7900, 7900HD Lo-Boy Models 3900, 5900 Convertible Models Pressure Relief Procedure Grounding Setup Change Engine to Motor Convertible Models OnlyStartup Spray Switch Tip Guard AssemblyWatchDog Protection System Clearing Tip ClogsProContractor and Ironman units only ProContractor units only Hose ReelProContractor and Ironman units Operation Main Menu Digital Tracking SystemChange Display Units Job GallonsPress and hold DTS button to clear error code to zero Cleanup Turn prime valve down Drain position Pressure Relief Procedure MaintenanceProblem Cause Solution TroubleshootingTroubleshooting Fluid Pump Runs Constantly Troubleshooting ProcedureControl Board Malfunction Volts Control Board Malfunction StepsConvertible Electric Motor Will Not Run Convertible Electric Motor Will Not Run Steps See step Is there over 10-20 AC volts? Beep Two blinks is the same as E=02 Digital Display MessagesPinion Assembly/Clutch Armature Removal Pinion Assembly/Clutch Armature/ClampInstallation Models Technical DataMetric Models Honda GX160 Engine Ansi Power Rating @ 3600 rpm Horsepower Honda GX200 Engine Ansi Power Rating @ 3600 rpm Horsepower Graco Information Graco Standard Warranty