Sanyo Sanyo Split System Air Conditoner, SAP-K77RAX service manual Refrigerant Flow Diagram

Page 19

4. REFRIGERANT FLOW DIAGRAM

4-1. Refrigerant Flow Diagram

Indoor Unit SAP-K77RAX

Outdoor Unit SAP-C77RAX

SAP-K97RAX

SAP-C97RAX

SAP-K127RAX

SAP-C127RAX

Indoor unit

 

Outdoor unit

 

Wide tube

 

Wide tube

service

Compressor

valve

Accumulator

*1

 

 

Heat exchanger

 

Heat exchanger

 

Narrow

 

 

tube

 

 

service

 

Narrow tube

valve

Capillary tube

Cooling cycle

O.D.

6.35mm

(1/4")

*1 O.D. 9.52 mm (3/8")...77, 97 class O.D. 12.7 mm (1/2")...127 class

Insulation of Refrigerant Tubing

IMPORTANT

Because capillary tubing is used in the outdoor unit, both the wide and narrow tubes of this air conditioner become cold. To prevent heat loss and wet floors due to dripping of condensation, both tubes must be well insulated with a proper insulation material. The thickness of the insulation should be a min. 8 mm.

After a tube has been insulated,

never try to bend it into a narrow CAUTION curve because it can cause the tube

to break or crack.

 

Insulation

Thickness:

Thickness:

Min. 8 mm

Min. 8 mm

 

Narrow tube

Wide tube

 

19

Image 19
Contents Split System AIR Conditioner Please Read Before Starting Table of Contents Appendix Operating Range Temperature Indoor Air Intake Temp Outdoor Air Intake TempIndoor Unit Unit SpecificationsOutdoor Unit SAP-K97RAX Outdoor Unit SAP-C127RAX SAP-K127RAXIndoor Unit SAP-K77RAX Major Component SpecificationsIndoor Unit SAP-K97RAX Indoor Unit SAP-K127RAX Outdoor Unit SAP-C77RAX Outdoor UnitOutdoor Unit SAP-C97RAX R115H5A / 1,100W Power Relay Model Rating EL200/240A1-F M AC277V 30A Other Component SpecificationsDimensional Data Unit mm 370 Indoor Unit SAP-K77RAX Outdoor Unit SAP-C77RAX Refrigerant Flow DiagramPerformance Data Performance chartsTemp. C Current Indoor Unit SAP-K127RAX Outdoor Unit SAP-C127RAX Air Throw Distance Charts Indoor Unit SAP-K97RAX Indoor Unit SAP-K127RAX Cooling Capacity Single Phase 50 Hz55 kW 460 m 3/h Electrical Data Electrical CharacteristicsController Electric Wiring Diagrams8FA2-5250-29800-0 Installation Site Selection Installation InstructionsAvoid Outdoor UnitRecommended Wire Length and Diameter Mounting on a Wall Remote Control Unit Installation PositionHow to Test Run the Air Conditioner How to remove the grille Removing and Installing the GrilleHow to replace the grille Address Setting of the Remote Control Unit Cooling Room Temperature ControlDry B zone Dry Operation DehumidificationCooling operation Dry a zoneAt least approx min Sec Freeze Prevention Cooling and DrySet Speed Automatic Fan Speed Cooling and Dry Check before and after troubleshooting TroubleshootingCheck indoor unit Air conditioner does not operateCircuit breaker trips or fuse blows Check outdoor unitNeither indoor nor outdoor unit runs Power is not suppliedThere is a possibility of short circuit Check Timer on the remote control unit Check remote control unitCheck fuse on the indoor P.C.Board Only outdoor unit does not run Check setting temperatureOnly outdoor fan does not run Some part of air conditioner does not operateOnly indoor fan does not run Only flap motor does not runOnly compressor does not run Poor cooling Air conditioner operates, but abnormalities are observedExcessive cooling Measurement of Insulation Resistance for Electrical Parts Power Supply CordMeasurement of Insulation Resistance Indoor UnitChecking Motor Capacitor Checking Continuity of Fuse on PCB AssyOI-852-6-4181-018-00-1 Contents FeaturesProduct Information Alert SymbolsInstallation Location Safety InstructionsUnit Display and Operation Button Names of PartsSymbols Remote Control Unit DisplayRemote Control Unit Back side of remote control unit Cover removed Temperature setting buttons TempCancel button Jumper wire for address switchingUnit Using the Remote Control UnitAir conditioner Indoor unit Receiver Remote control ACL buttonAutomatic fan speed Operation with the Remote Control UnitManual fan speed Economy Mode Hours Using the 12-HOUR on and OFF TimerTimer times appear in the display for only 3 seconds Timer settingStop Operate Hour Hours Using the 1-HOUR OFF TimerTips for Energy Saving Do notKnob Adjusting the Airflow DirectionButton ON/OFF Care and Cleaning Operating Range TroubleshootingCenter manual