Sanyo Sanyo Split System Air Conditoner, SAP-K77RAX service manual Outdoor Unit, Avoid

Page 33
Fig. 4

7-1-2. Outdoor Unit

AVOID:

heat sources, exhaust fans, etc. (Fig. 4)

damp, humid or uneven locations.

DO:

NO

Hot air

Outdoor unit

Exhaust fan

Heat source

choose a place as cool as possible.

choose a place that is well ventilated.

allow enough room around the unit for air intake/exhaust and possible maintenance. (Fig. 5a)

provide a solid base (level concrete pad, concrete block, 10 40 cm beams or equal), a minimum of 10 cm above ground level to reduce humidity and protect the unit against possible water damage and decreased service life. (Fig. 5b)

Install cushion rubber under unit’s feet to reduce vibration and noise. (Fig. 5c)

use lug bolts or equal to bolt down unit, reducing vibration and noise.

Install in a location where no antenna of a television or radio exists within 3 meters.

Air intake

Min. 5 cm

Valve

 

 

 

side

 

 

 

Min.

 

 

 

25 cm

Min.

Air discharge

Min.

5 cm

 

 

20 cm

 

 

 

Fig. 5a

Anchor bolts (4 pcs.)

Air intake

Min. 10 cm

Concrete or equal

About

 

10

cm

40

About

 

 

 

 

cm

 

 

 

 

Fig. 5b

Obstacle above

Airdischarge

 

 

 

Obstacle

 

 

 

Min.

Min.

 

 

 

2 m

2 m

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Ground

Min. 5 cm

Air intake

Cushion rubber (Locally purchased)

Fig. 5c

33

Image 33
Contents Split System AIR Conditioner Please Read Before Starting Table of Contents Appendix Operating Range Temperature Indoor Air Intake Temp Outdoor Air Intake TempUnit Specifications Indoor UnitOutdoor Unit SAP-K97RAX Outdoor Unit SAP-C127RAX SAP-K127RAXIndoor Unit SAP-K77RAX Major Component SpecificationsIndoor Unit SAP-K97RAX Indoor Unit SAP-K127RAX Outdoor Unit SAP-C77RAX Outdoor UnitOutdoor Unit SAP-C97RAX R115H5A / 1,100W Power Relay Model Rating EL200/240A1-F M AC277V 30A Other Component SpecificationsDimensional Data Unit mm 370 Indoor Unit SAP-K77RAX Outdoor Unit SAP-C77RAX Refrigerant Flow DiagramPerformance Data Performance chartsTemp. C Current Indoor Unit SAP-K127RAX Outdoor Unit SAP-C127RAX Air Throw Distance Charts Indoor Unit SAP-K97RAX Indoor Unit SAP-K127RAX Cooling Capacity Single Phase 50 Hz55 kW 460 m 3/h Electrical Data Electrical CharacteristicsController Electric Wiring Diagrams8FA2-5250-29800-0 Installation Site Selection Installation InstructionsAvoid Outdoor UnitRecommended Wire Length and Diameter Mounting on a Wall Remote Control Unit Installation PositionHow to Test Run the Air Conditioner Removing and Installing the Grille How to remove the grilleHow to replace the grille Address Setting of the Remote Control Unit Cooling Room Temperature ControlCooling operation Dry Operation DehumidificationDry a zone Dry B zoneFreeze Prevention Cooling and Dry At least approx min SecSet Speed Automatic Fan Speed Cooling and Dry Check before and after troubleshooting TroubleshootingCircuit breaker trips or fuse blows Air conditioner does not operateCheck outdoor unit Check indoor unitPower is not supplied Neither indoor nor outdoor unit runsThere is a possibility of short circuit Check remote control unit Check Timer on the remote control unitCheck fuse on the indoor P.C.Board Only outdoor unit does not run Check setting temperatureOnly indoor fan does not run Some part of air conditioner does not operateOnly flap motor does not run Only outdoor fan does not runOnly compressor does not run Air conditioner operates, but abnormalities are observed Poor coolingExcessive cooling Measurement of Insulation Resistance Power Supply CordIndoor Unit Measurement of Insulation Resistance for Electrical PartsChecking Motor Capacitor Checking Continuity of Fuse on PCB AssyOI-852-6-4181-018-00-1 Contents FeaturesInstallation Location Alert SymbolsSafety Instructions Product InformationUnit Display and Operation Button Names of PartsSymbols Remote Control Unit DisplayRemote Control Unit Cancel button Temperature setting buttons TempJumper wire for address switching Back side of remote control unit Cover removedAir conditioner Indoor unit Receiver Remote control Using the Remote Control UnitACL button UnitOperation with the Remote Control Unit Automatic fan speedManual fan speed Economy Mode Timer times appear in the display for only 3 seconds Using the 12-HOUR on and OFF TimerTimer setting HoursTips for Energy Saving Using the 1-HOUR OFF TimerDo not Stop Operate Hour HoursAdjusting the Airflow Direction KnobButton ON/OFF Care and Cleaning Operating Range TroubleshootingCenter manual