Heatiator ECO-ADV-WS22 warranty G. Masonry Chimney

Page 35

G. Masonry Chimney:

	Spark Arrestor Cap
	Concrete Cap	Fireclay Flue Liner
	Concrete Cap	With Air Space
		With Air Space
	Rafter
		Flashing
	1 in. (25mm) Clearance
	With Firestop
	Ceiling Joist	Eave
		Eave
	Combustible Wall
	Thimble,
	12 in. (305mm)
	Of Brick	Sheathing
		Sheathing
		Outside Air Rear Vent
	Floor	Outside Air
	Floor	Termination Cap
	Protector	Termination Cap
	Protector
		Airtight
		Cleanout Door

Figure 35.1 Masonry Chimney

WARNING! Risk of Fire!

Inspection of Chimney:

•Chimney must be in good condition and meets the minimum standard of NFPA 211.

WARNING! Risk of Asphyxiation!

•DO NOT CONNECT THIS APPLIANCE TO A CHIMNEY FLUE SERVICING ANOTHER APPLIANCE OR TO ANY AIR DISTRIBUTION DUCT OR SYSTEM.

This may allow flue gases to enter the house.

Heatilator • ECO-ADV-WS22 • 7057-128C • August 13, 2010

Image 35

Contents Model ECO-ADV-WS22 Wood Burning Stove DO DIS NOT C AR DWS22 Test Lab and SAMPLE OF SERIAL NUMBER / SAFETY LABELCongratulations LOCATION Back of ApplianceUser’s Guide TABLE OF CONTENTSInstaller’s Guide Safety Alert KeyWARRANTY PERIOD Warranty PolicyHEATILATOR ECO-CHOICEWARRANTY WARRANTY COVERAGEWARRANTY EXCLUSIONS WARRANTY EXCLUSIONSThis warranty is void if WARRANTY COVERAGEA. Appliance Certification D. BTU & Efficiency SpecificationsC. Glass Specifications 1 Listing and Code ApprovalsHot glass will cause burns User Guide2 Operating Instructions A. Your Wood Appliance - General Operating PartsE. Seasoned Wood B. Fire SafetyD. Combustible/Non-combustibleMaterials C. Overfiring3. Final Stage G. Burning Process1. Kindling or First Stage 2. Second StageFor maximum operating efficiency H.Burn Rate Air ControlI. Burn Rates and Operating Efficiency Figure 10.1 - Burn Rate Air ControlBaffle Board J. Correct Baffle & Blanket PlacementCeramic Blanket Back of FireboxDo NOT K. Building A FireHard woods L.Wood FuelWARNING! Risk of Fire Soft woods7.Snap Disc Location M. Blower Operating InstructionsN. Clear Space Figure 14.2 - Snap Disc LocationO. Opacity Smoke P. Frequently Asked QuestionsISSUES SOLUTIONSADD NEWSPAPER The stove is ready for normal operationQ. Quick Start Guide LOAD WOODWARNING! Risk of Fire 3 Maintenance and ServiceA. Disposal of Ashes C. Appliance Inspection - RoutineFrequency As desired D. Glass CleaningE. Firebrick Inspection F. Quick Reference Maintenance Guide Possible Cause 4 Troubleshooting GuideStart Fire Problems SolutionWARNING! Risk of Fire or Injury 5 Service Parts ReplacementA. Glass Replacement B. Snap Disc ReplacementFigure Figure 22.1 - Baffle C.Baffle RemovalD. Door Handle Assembly NOTE Service Space E. Tube Channel Assembly ReplacementRemoving Tube Channel Assembly Replacing Tube Channel AssemblyB. Draft Installer’s GuideA. Design and Installation Considerations 6 Getting StartedE. Chimney Termination Requirements D. Locating Your Stove & ChimneyFlat Roof F. 2-10-3RuleWARNING! Risk of Fire H. Fire SafetyG. Tools And Supplies Needed I.Inspect Appliance and ComponentsFigure 29.2 -TopView 7 Dimensions and ClearancesA. Appliance Dimensions Figure 29.1 - Front ViewSEE PIPE MANUFACTURERS CLEARANCES - NOT TESTED B. Clearances to Combustibles UL and ULCSee Figure C. Hearth Protection RequirementsCANADA FLOOR PROTECTIONConverting R to k Thermal Conductivity k valueThermal Resistance R value Converting k to RC. Larger Chimneys 8 Venting and Chimney SystemsA. Venting Systems B. InspectionsWARNING! Risk of Fire E. Chimney Height / Rise and RunF.Factory-BuiltChimney S629M, STANDARD FOR 650oC FACTORY-BUILTCHIMNEYSG. Masonry Chimney H. Masonry Chimney Liner as a Thimble I.Air ClearancesJ. Thimble Solid Pack Chimney with Metal SupportsHeatilator ECO-ADV-WS22 7057-128C August as a Thimble Cont’dSolid Pack Chimney with Metal Supports WARNING! Risk of FireFigure 39.2 - Alternate Floor Installation A. Outside Air Kit Installation9 Appliance Set-up Items Needed for Installation not suppliedWARNING! Risk of Asphyxiation B. Mobile Home InstallationCAUTION! Risk of Shock C. Blower Installation OptionalD. Adjusting the Blower Speed Control A. Exploded View 13 Inlet Assembly14 Door Assembly Reference MaterialsDESCRIPTION Brick AssemblyB. Service Parts & Accessories HOW TO ORDERDESCRIPTION B. Service Parts & Accessories Cont’dHOW TO ORDER AccessoriesPerformed By C. Service And Maintenance LogDate of Service Description of ServicePerformed By C. Service And Maintenance Log Cont’dDate of Service Description of ServiceHeatilator ECO-ADV-WS22 7057-128C August D.Homeowner’s NotesDO DIS NOT C AR D E. Contact InformationHearth & Home Technologies 1445 North Highway Colville, WA Division of HNI INDUSTRIES