Quadra-Fire SANTAFEI-CE-MBK, CASTILEI-CE-MBK owner manual Contact Information

Page 36

R

CONTACT INFORMATION:

Hearth & Home Technologies

1445 North Highway

Colville, WA 99114

Division of HNI CORPORATION

www.quadrafire.com

Please contact your Quadra-Fire dealer with any questions or concerns.

For the number of your nearest Quadra-Fire dealer

visit our website at www.quadrafire.com

NOTICE

DO NOT DISCARD THIS MANUAL

• Important operating and

Read, understand and

Leave this manual with

maintenance instruc-

follow these instruc-

party responsible for use

tions included.

tions for safe installa-

and operation.

 

tion and operation.

 

DO DISCARDNOT

We recommend that you record the following pertinent information for your CASTILE or SANTA FE INSERT

Date purchased/installed:

 

 

 

 

Serial Number:

 

Location on appliance:

 

Dealership purchased from:

 

Dealer phone:

 

Notes:

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

This product may be covered by one or more of the following patents: (United States) 6830000 and 5582117 or other U.S. and foreign patents pending.

 

 

 

 

Page 36

7069-101B

October 27, 2011

Image 36
Contents Castile & Santa FE Pellet Insert Hot glass will cause burnsCastile & Santa Fe CE Insert Welcome to the Quadra-Fire FamilyTable of Contents Castile & Santa Fe CE Insert Castile & Santa Fe CE Insert Specifications Glass SpecificationsListing and Code Approvals Appliance CertificationUser’s Guide Operating InstructionsCastile & Santa Fe CE Insert Fire Safety Combustible/Non-Combustible MaterialsFuel Material and Fuel Storage Castile & Santa Fe CE Insert General Operating Information Before Your First FireFilling the Hopper with Fuel Thermostat Calls For HeatFire Characteristics Feed Rate Adjustment InstructionsFeed Adjustment Control Rod Wing Nut Set Screw Castile & Santa Fe CE Insert Starting Your First FireCastile & Santa Fe CE Insert Ignition Cycles Clear Space Do not Leave Firepot Floor OpenQuick Reference Maintenance Chart Types of FuelCleaning Firepot with Cleaning Rod & Firepot Clean-Out Tool Cleaning Ash Pan/DrawerSee .1 on Disposal of Ashes Frequency As needed Ash Removal from FireboxCleaning Heat Exchanger Chambers & Drop Tube Cleaning Beneath Heat ExchangerCleaning the Hopper Cleaning the GlassCleaning Combustion Blower Requires No Lubrication Preparing Firebox for Non-Burn SeasonDoor Latch Inspection Task Contact your local dealerTall, Lazy Flame, Orange in Color Troubleshooting for Homeowner Frequently Asked QuestionsGetting Started Appliance LocationFloor Support Castile & Santa Fe CE Insert Thermostat Location Tools And Supplies NeededPre-Burn Check List Inspect Appliance and ComponentsDimensions and Clearances Appliance DimensionsMinimum Opening for Masonry and Factory-Built Fireplaces Castile & Santa Fe CE Insert Floor ProtectionPrefabricated Metal Chimney Negative Pressure, Shut-Down and Electrical Power Failure Vent InformationVenting Termination Requirements Avoiding Smoke and OdorsVent Configurations Negative PressureDraft Minimum Vacuum Requirements 095Castile & Santa Fe CE Insert Chimney and Exhaust Connection Castile & Santa Fe CE Insert Pellet Venting Charts Miniumum Vertical Vent for Two ElbowsVenting Systems Full Reline With Horizontal Outside AirOutside Air Termination At Chimney Top Appliance Set-Up Leveling SystemOutside Air Kit Instructions Adjustable Hearth Support Castile & Santa Fe CE Insert Door Handle RemovalDoor Removal Install Front Last Surround & Trim Set, Econo 34.2Castile & Santa Fe CE Insert Surround and Cast Trim Set Sheet metal screws on each side provided with the kitCastile & Santa Fe CE Insert Panel and Trim Set Completed ViewTwo Piece Log Set Installation Castile & Santa Fe CE Insert Thermostat Installation Contact Information