Empire Comfort Systems CIVF-25-21 installation instructions HOW to Order Repair Parts

Page 21

9.Slight smoke or odor during initial operation.

a.Residues from manufacturing processes and logs curing

-Problem will stop after a few hours of operation.

10.Heater produces a whistling noise when main burner is lit.

a.Turning control knob to HI position when main burner is cold - Turn control knob to LO position and let warm up for a minute.

b.Air in gas line - Operate main burner until air is removed from line. Have gas line checked by local gas company.

c.Air passageways on heater blocked - Observe minimum installation clearances (see page 8).

d.Dirty or partially clogged main burner orifice - Clean main burner and main burner orifice or replace main burner orifice.

11.Heater produces a clicking/ticking noise just after main burner is lit or shut off.

a.Metal expanding while heating or contracting while cooling

-This is common with most heaters. If noise is excessive, contact service person.

12.Heater produces unwanted odor.

a.Heater burning vapors from paint, hair spray, glues, cleaners, chemicals, new carpet, etc. - Open window to ventilate room. Stop using odor causing products while heater is operating.

b.Low fuel supply - Refill supply tank.

c.Gas leak - Locate and correct all leaks.

13.Heater shuts off in use (ODS operates).

a.Not enough fresh air is available - Open window and/or door for ventilation.

b.Low line pressure - Contact local gas company.

c.ODS/pilot is partially clogged - Clean ODS/pilot.

14.Gas odor even when control knob is in OFF position.

a.Gas leak - Locate and correct all leaks.

b.Control valve defective - Replace control valve.

15.Gas odor during combustion.

a.Foreign matter between logs and main burner - remove foreign matter.

b.Gas leak - Locate and correct all leaks.

HOW TO ORDER REPAIR PARTS

Parts can be ordered only through your service person or dealer. For best results, the service person or dealer should order parts through the distributor. Parts can be shipped directly to the service person/dealer.

All parts listed in the Parts List have a Part Number. When ordering parts, first obtain the Model Number from the name plate on your equipment. Then determine the Part Number (not the Index Number) and the Description of each part from the following appropriate illustration and list. Be sure to give all this information.

Heater Model Number

 

Heater Serial Number

Part Number

 

 

Part Description

 

 

Type of Gas (Propane or Natural)

 

 

 

 

Do not order bolts, screws, washers or nuts. They are standard hardware items and can be purchased at any local hardware store. Shipments contingent upon strikes, fires and all causes beyond our control.

Empire Comfort Systems, Inc. Nine Eighteen Freeburg Ave. Belleville, Illinois 62222-0529

16938-3-0806

Page 21

Image 21
Contents Installation Instructions Table of Contents Minimize this effect. The use of this fan will also improve Important Safety InformationLP-GAS Warning Odor Safety Information for Users of LP-GASInstructions to Installer SpecificationsQualified Installing Agency IntroductionUnusually tight construction is defined as construction where Unusually Tight ConstructionPressure Testing of the Gas Supply System Installing a New Main Gas CockRecommended Gas Pipe Diameter Checking Manifold PressureInstallation on Rugs and Tile ClearancesClearances Figures 2, 3 Appliance Hardware Package Appliance Hardware Package Parts ListDetailed Instructions Follow Assembly of Stove Casting16938-3-0806 Assembly of Stove Casting Wire Channel Installation Optional Stone Inlay InstallationInstallation of Optional Stone Inlay Parts ListOperating Guidelines LOG PlacementInitial Lighting Figure Standing Pilot OperationLighting Instructions For Your Safety Read Before LightingCorrect Pilot Flame Pattern Incorrect Pilot Flame Pattern Pilot Flame CharacteristicsCleaning the Log Set and Firebox Main Burner Flame CharacteristicsWiring Wiring Diagram Figure MaintenanceTroubleshooting Delayed ignition of main burnerMain burner does not light after ODS/pilot is lit HOW to Order Repair Parts Parts List for CIVF-25-21 Parts List for Stove CastingParts View for Stove Casting Parts View for CIVF-25-21 Optional Blower Installation Instructions Installing Optional CIB-2 BlowerFan Control Wiring CleaningBlower Motor Index Part DescriptionService Notes