Desa (V)KC42PE Replacement Parts, Service Hints, Technical Service, Specifications

Page 34
Replacement Parts

Replacement Parts

Note: Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty.

Parts Under Warranty

Contact authorized retailers of this product. If they can not supply original replacement part(s), call DESA’s Customer Service Department at 1-866-672-6040.

When calling DESA, have ready

your name

your address

model and serial numbers of your fireplace

how fireplace was malfunctioning

type of gas used (propane/LP or natural gas)

purchase date

Usually, we will ask you to return the part to the factory.

Parts Not Under Warranty

Contact authorized retailers of this product. If they can not supply original replacement part(s), call DESA at 1-866-672-6040 for referral infor- mation.

When calling DESA, have ready

model number of your fireplace

the replacement part number

Service Hints

When Gas Pressure Is Too Low

• pilot will not stay lit

• burners will have delayed ignition

• fireplace will not produce specified heat

• propane/LP gas supply might be low (propane/ LP units only)

You may feel your gas pressure is too low. If so, contact your local gas supplier.

Technical Service

You may have further questions about installation, operation or troubleshooting. If so, contact DESA’s Customer Service Department at 1-866-672-6040. When calling, please have your model and serial numbers of your heater ready.

You can also visit DESA’s technical service web site at www.desatech.com.

Specifications

KC42NE and VKC42NE

• Rating: 25,000/36,000 Btu/hr

• Gas Type: Natural Gas Only

• Ignition: Electronic

• Manifold Pressure: 3.5" w.c.

• Minimum Inlet Supply Pressure: 5.5" w.c.

• Firebox Dimensions (HxWxD) [Flanges and Standoffs Not Included in Measurement]: 40" x 48" x 23 1/2" (1016 x 1219 x 599 mm)

KC42PE and VKC42PE

• Rating: 23,000/33,000 Btu/hr

• Gas Type: Propane/LP Gas Only

• Ignition: Electronic

• Manifold Pressure: 10.0" w.c.

• Minimum Inlet Supply Pressure: 11.0" w.c.

• Firebox Dimensions (HxWxD) [Flanges and Standoffs Not Included in Measurement]: 40" x 48" x 23 1/2" (1016 x 1219 x 599 mm)

34

www.desatech.com

116240-01E

Image 34
Contents WHAT TO DO IF YOU SMELL GAS DANGER Carbon monoxide Table of ContentsSafety Information poisoning may lead to deathSafety information ContinuedIdentification Safety informationProduct Local CodesFigure 3 - Fireplace Bottom Dimensions Product FeaturesPre-Installation Preparation Location and space requirementsContinued ClearancesPreparation Pre-InstallationInstallation ContinuedD E B L Location of Termination CapFigure 7 - Minimum Clearances for Termination Cap Venting Installation Instructions Continued Venting Installation instructionsINSTALLATION PLANNING Figure 8 - Vent Pipe ConnectionsFigure 12 - Connecting Vent Cap with Figure 10 - Installing Horizontal Vent CapFigure 11 - Installing Siding Standoff ContinuedSquare Termination GROUND FLOOR INSTALLATIONContinued VerticalContinued CORNER INSTALLATIONSNORKEL TERMINATION INSTALLATION 90 ElbowContinued HORIZONTAL SYSTEM INSTALLATIONUSING TWO 90 ELBOWS with Termination at 90 with FireplaceFigure 20 - Installing Firestop installation for vertical terminationFlat Ceiling Installation ContinuedContinued Configuration Using Two 90 ElbowsConfiguration Using One 90 Elbow Figure 21 - Vertical VentingContinued Configuration Using Two 90 ElbowsConfiguration With No Horizontal Run Vertical VentingDESA 5/8 Pipe & Vent Kits Number Description parts list for venting kits and componentsContinued Number DescriptionInstalling optional blower accessories Fireplace InstallationCHECK GAS TYPE Continued Model BKT InstallationFigure 28 - Blower Model BKT Blower Wiring Diagram Installing Gas Piping to Fireplace LocationInstallation Items Needed Figure 30 - External Regulator with Vent Installation Items NeededContinued Pointing Down Propane/LP OnlyContinued CHECKING GAS CONNECTIONSFigure 36 - Removing Louver Panel Pressure Testing Fireplace Gas ConnectionsRemoving Louver Panels Removing Glass DoorInstalling lava rock and glowing embers Figure 39 - Installing Rear Brick Panel Installing Lava Rock and Glowing Embers, pageFigure 40 - Installing the WRC Remote Receiver Figure 41 - Installing Battery into Back of24V AC IGNITOR LEADPILOT 120V AClighting instructions for your safety Read before lightingOperating Fireplace TO TURN OFF GAS TO APPLIANCEContinued see Troubleshooting, pagesee Troubleshooting, page Figure 44 - Correct Pilot Flame PatternCleaning and Maintenance CAUTION Do not vacuum if pieces are hotOBSERVED PROBLEM Cleaning and MaintenanceTroubleshooting venting systemWiring Diagram, page TROUBLESHOOTINGContinued WARNING If you smell gas Shut off gas supply Technical Service Replacement PartsService Hints SpecificationsAccessories 7 8 24 22 23 4 1 9 11 3 14 16116240-01E PARTS LIST illustrated parts breakdown Burner Pan Assembly KEEP THIS WARRANTY Warranty InformationLIMITED WARRANTY DIRECT-VENTFIREPLACE