Desa VYGF33PRC installation manual Installing Logs, Vygf Models Only

Page 17

INSTALLATION

Continued

INSTALLING LOGS

CAUTION: Do not remove the dataplatesattachedtotheheater base assembly. The data plates contain important warranty and safety information.

WARNING:You must operate this ﬁreplace with the ﬁreplace screen in place. Make sure ﬁre- place screen is in place before running ﬁreplace.

Crossover

Log #3

WARNING:Failuretoposition thepartsinaccordancewiththese diagrams or failure to use only parts speciﬁcally approved with this heater may result in property damage or personal injury.

WARNING: After installa- tion and periodically thereafter, check to ensure that no ﬂame comes in contact with any log. WiththeheatersettoHigh,check to see if ﬂame contact any log. If so, reposition logs according to the log installation instructions in this manual. Flames contact- ing logs will create soot.

It is very important to install the logs exactly as instructed. Do not modify logs. Only use logs supplied with ﬁreplace.

VYGF Models Only

1.Place back log #1 on grate to ﬁt as illustrated in Figure 28. Make sure middle section at bottom of log set is seated into “U”-shaped cutout in center of chassis (see Figure 28). IMPORTANT: Make sure log does not cover any burner ports (see Figure 29).

2.Place front log #2 against front grate prongs as shown in Figure 28.

3.Place crossover log #3 on top of front and back logs as shown in Figure 28.

4.Install ﬁreplace screen by slipping notches of ﬁreplace screen over screws on front of ﬁreplace (see Figure 30).

	Front	Back
	Log #2	Back
	Log #2	Log #1
		Log #1
	Grate
	Prongs

ChassisBurner

Figure 28 - Installing Log Set

Burner Ports

Log Set

Figure 29 - Installing Log Set, Top View

Notches

Screws for

Mounting Screen

Figure 30 - Installing Fireplace Screen

113109-01B

www.desatech.com

17

Image 17

Contents Patent Pending What to do if YOU Smell GASTable of Contents Safety Information Product Identification Log Base AssemblyLocal Codes Product FeaturesUnpacking AIR for Combustion VentilationDetermining FRESH-AIR Flow for Heater Location Providing Adequate VentilationUnusually Tight Construction Conﬁned and Unconﬁned SpaceVentilation Air From Outdoors Ventilation AIRVentilation Air From Inside Building Installing Hood InstallationCheck GAS Type Electrical HookupRepeat steps 1 through 6 for other side Installation ClearancesPlacing Hearth Base Accessory Against Wall Conventional Fireplace InstallationModels VYGF33PRB and VYGF33NRB BUILT-IN Fireplace InstallationModels FPVF33PRA and FPVF33NRA Connecting Duplex OutletInstallation Items Needed Installing GAS Piping to Fireplace LocationMantel Clearances for Built-In Installation Propane/LP Connecting Fireplace to GAS SupplyNatural Gas Test Pressures In Excess Of 1/2 Psig 3.5 kPa Checking GAS ConnectionsTest Pressures Equal To or Less Than 1/2 Psig 3.5 kPa Pressurize supply piping system by eitherVygf Models Only Installing LogsFpvf Models Only Installing Remote Receiver UnitFor Your Safety Read Before Lighting Installing 9-VOLT BatteriesInstalling 9-Volt Battery in Receiver Installing 9-Volt Battery in Hand-Held Remote Control UnitPilot Propane/LP Lighting InstructionsTo Turn OFF GAS To Appliance Manual Lighting ProcedureOptional HAND-HELD Remote Operation ON/OFF Series Model GhrcbOptional Blower Operation Thermostat Series Model GhrctbPilot Flame Pattern Inspecting BurnerBurner Flame Pattern Burner Primary AIR HolesLogs Cleaning MaintenanceBurner Injector Holder and Pilot AIR Inlet Hole Observed Problem Possible Cause Remedy TroubleshootingDiagram, Maintenance, Gas leak. See Warning Fireplace produces unwantedSpecifications Wiring DiagramReplacement Parts Technical ServiceModels VYGF33PRC and VYGF33NRC Shown Illustrated Parts BreakdownParts List Models FPVF33PRA and FPVF33NRA KEY Part Number FPVF33PRA FPVF33NRA Description QTY Firebox Models VYGF33PRC and VYGF33NRC KEY Part Number Description QTY Firebox Models FPVF33PRA and FPVF33NRA Parts List Accessories WALL-MOUNT ON/OFF Switch Receiver and HAND-HELD Remote Control KIT Ghrcb SeriesCabinet Mantel and Full Hearth Base Laminate Trim for Hearth or MantelLimited Warranty VENT-FREE GAS Fireplace Warranty InformationKeep this Warranty