Lopi Leyden Pellet Stove manual

Page 1

Leyden

Pellet Stove

• Horizontal Or Vertical Vent

• Freestanding Stove

• Mobile Home Approved

• Class A Chimney Retrofit

• Hearth Stove into Existing Masonry Chimney , Masonry Fireplace, or Z.C. Fireplace

Tested and Listed by

Omni-Test Laboratories, Inc.

Beaverton, Oregon

Report # 028-S-77-2

ASTM E1509-2004

- - Please read this entire manual before installation and use of this pellet fuel- burning room heater. Failure to follow these instructions could result in property damage, bodily injury, or even death.

-- Contact local building or fire officials about restrictions and installation inspection requirements in your area.

-- Save these instructions.

Installer: After installation give this manual to the home-owner and explain operation of this stove.

$10.00

 Copyright 2007, T.I.

Part # 100-01184

4061016	4800 Harbour Pointe Blvd. SW
	Mukilteo, WA 98275

Image 1

Contents Leyden Introduction 2IntroductionImportant Information Travis IndustriesTable of Contents 4Safety Precautions Mobile Home Safety Precautions6Specifications Planning The Installation Installation OptionsStove Placement Before You BeginInstallation Clearances Straight InstallationClearances Corner Maximum Venting Distance Venting the Pellet StovePellet Vent Type Installing the Pellet VentPellet Vent Termination Outside Air used for combustion Mobile Home RequirementsBaffle Installation Alcove Installation RequirementsRestrictor Adjustment Door Seal VerificationThermostat Installation Installation Example Direct Through-the-wall Installation Min Ceiling Support / Fire Stop Spacer Vent Installation Example Interior Vertical InstallationInstallation Example Class a Chimney Retrofit Installation Example Masonry Fireplace Hearth Stove Vertical Cap Cover Plate non-combustible Storm Collar Vent Flex Section Installation Example Freestanding Masonry Chimney0Operation Safety NoticeLocation of Controls Starting the Heater for the First TimeLoading Pellets Operation2Two Modes of Operation To Adjust the Heat Manual Mode2Operation To StartTo Adjust Room Temperature or Start the Stove Auto Mode4Operation Adjusting the Fan SpeedPower Outages Fault LightStart-Up Sequence Manual Auger Button6Operation Using a Pellet/Corn Mix with This HeaterDaily Maintenance whenever using the stove Maintenance2Inspect the Burn Make Sure Pellets are Not Piling UpCleaning the Firepot 8MaintenanceCheck Firepot for Clinkers Door Opening Bi-Weekly Maintenance or every 10 bags of pellets 2MaintenanceBi-Weekly Maintenance or every 10 bags of pellets Maintenance3Clean the Baffles Sweep Ash Into Ashpan Check Ashpan, Dispose if necessary Clean the GlassYearly Maintenance or every two tons 4MaintenanceClean the Vertical Exhaust Duct Maintenance3 Clean the Exhaust Blower 6MaintenanceClean the Vent Clean the Convection BlowerAdjusting the Door Hinge and Latch Check for Air Leaks Around the Door, Glass, and AshpanDoor Replacement Replacement PartsReplacement Parts Convection Fan Normal Operating SoundsSafety Label Years 1 & 2 Coverage Parts & Labor Limited 7 Year Warranty2Index