Reliance Water Heaters 606 Series Typical Installation, GET to Know Your Water Heater GAS Models

Page 5

TYPICAL INSTALLATION

GET TO KNOW YOUR WATER HEATER - GAS MODELS

A	VENT PIPE	I	GROUND JOINT UNION	Q	TEMPERATURE-PRESSURE
B	DRAFT HOOD	J	DRIP LEG (SEDIMENT TRAP)		RELIEF VALVE
C	ANODE	K	INNER DOOR	R	RATING PLATE
D	HOT WATER OUTLET	L	OUTER DOOR	S	FLUE BAFFLE(S)
E	OUTLET	M	UNION	T	THERMOSTAT
F	INSULATION	N	INLET WATER SHUT-OFF VALVE	U	DRAIN VALVE
G	GAS SUPPLY	O	COLD WATER INLET	V	PILOT AND MAIN BURNER
H	MANUAL GAS SHUT-OFF VALVE	P	INLET DIP TUBE	W	FLUE
				X	DRAIN PAN

*INSTALL IN ACCORDANCE WITH LOCAL CODES.

*DRIP LEG AS REQUIRED BY LOCAL CODES.

*ALL PIPING MATERIALS TO BE SUPPLIED BY CUSTOMERS.

**CLOSED WATER SYSTEMSARE THOSE WITH BACK FLOW PREVENTION DEVICES INSTALLED IN THE INLET WATER SERVICE LINE.

FIGURE 1.

(T) THERMOSTAT

(V) PILOT & MAIN BURNER - NATURAL GAS

(V) PILOT & MAIN BURNER - PROPANE GAS

THERMOCOUPLEMAIN BURNER

PILOT

BURNER

5

Image 5

Contents Residential GAS Water Heaters Important Definitions Safe INSTALLATION, USE and ServiceGeneral Safety Introduction Table of ContentsGET to Know Your Water Heater GAS Models Typical InstallationMixing Valve Usage Removing the OLD Water Heater Materials and Basic Tools Needed Deciding on the Type of InstallationFacts to Consider about the Location Locating the NEW Water HeaterInsulation Blankets ALL AIR from Inside Buildings See Figures 10 Page Section a Galvanized Piping Installing the NEW Water HeaterSection B Copper Sweat Piping Page TEMPERATURE-PRESSURE Relief Valve Venting Filling the Water HeaterGAS Piping Sediment Traps GAS Piping with Flexible ConnectorFor Your Safety Read Before Lighting For Your Safety Read Before Lighting For Your Information Temperature RegulationStart UP Conditions Draft Hood OperationThermal Expansion Smoke / OdorStrange Sounds Smelly WaterHigh Water Temperature Shut OFF System Periodic MaintenanceVenting System Inspection Burner InspectionTEMPERATURE-PRESSURE Relief Valve Operation Burner CleaningHousekeeping Anode ROD InspectionService Drain Valve Washer ReplacementLeakage Checkpoints Problem Cause Solution Troubleshooting GuidelinesT&P Relief Valve Repair Parts ListDrain PAN Conditions and Exceptions Service and Labor ResponsibilityModel Series Installation Information Claim ProcedureLimitation on Implied Warranties DisclaimersLindahl Parkway Ashland City, TN