Burnham
SERIES 2
manual
Service Notes
Install
Wiring Schematic, Zone Valves
Canopy Assembly
Safety
Section III Service
Page 45
Service Notes
45
Page 44
Page 46
Image 45
Page 44
Page 46
Contents
PartNo.81417032R10-11/99
Price $3.00
Page
202
Clearances
Canada
Remove Crate
Determine type of space. Divide Volume by Total Input
Boilerpiping
Oxygen Corrosion
Length Inch w.c. Pressure Drop Feet
Equivalent Length of Fittings
Installblockedventswitch
Refer to in this manual
Ifanexistingboilerisremoved
Both of the aforementioned standards, Ansi
Seal any unused openings in the common venting system
Plug-in Damper Installation
54/ANSIZ223.1
Ventdampersequenceofoperation
Effikal and Johnson Damper
Vent Damper Schematic Wiring Diagram
Sequence of Operation Normal Operation
Safety Shutdown
Page
Vent Damper will close see Paragraph 17E
Page
Pilot
Sequence of Operation Normal Operation
Wiring Schematic, Zone Valves
Initial Start
Section II Operating Instructions
Top View of SV9500, SV9600 VR Gas Valves 21460147
For Your Safety Read Before Operating
Lighting Instructions
81460177
Check GAS Input Rate to Boiler
LP Gas Input
Check Pilot Burner Flame
Check Ignition System Safety SHUT-OFF Device
Move Jumper
Combustion Chamber BURN-OFF
Typical Pilot Flame, Honeywell Q3450
Troubleshooting Guide, Honeywell Intermittent Ignition
Section III Service
Burner Cleaning and Installation
Lubrication
Manifold and Main Burners
Pilot Burner and Gas Valve
Contact Regional Office Indicated for your State
Burnham Corporation Regional Offices
Section Assembly and Canopy Group
Canopy Assembly
Key Description Boiler Qty
Base Assembly
USS
Manifold and Main Burners Inch Main Burners
Manifold and Main Burners 1 Inch Main Burners Only
Key Description Quantity
Manifold and Main Burners Mm Main Burners
Manifold and Main Burners 50 mm Main Burners Only
Intermittent Ignition Only
40MM Main Burners only
Volt Continuous Ignition Standing Pilot Natural Gas Only
Volt Continuous Ignition Standing Pilot LP Gas Only
Natural G as, Sea Level to 2000 Ft
Burner Only 40mm Burner Only
Burner Only 40mm Burner Only
40mm Burners Only
Service Notes
Key Quantity Description
Key Description Quantity
Water Trim
Nipple, 1¼ NPT x 806600005
Transformer Continuous and Gravity Circulation Only
Draft Hood Carton
Vent Damper Carton U.S.A. Standard Canada Optional
Vent Reducer
Top
Page
Image
Contents