Empire Comfort Systems VFDR30LBN-1 installation instructions Installation Instructions

Page 1

INSTALLATION INSTRUCTIONS

AND OWNER'S MANUAL

Vented/Vent-Free Burner and Logs

5 Log Set Shown

Installer: Leave this manual with the appliance.

Consumer: Retain this manual for future reference.

This appliance may be installed in an aftermarket permanently located, manufactured (mobile) home, where not prohibited by local codes.

This appliance is only for use with the type of gas indicated on the rating plate. This appliance is not convertible for use with other gases.

WARNING: If the information in this manual are not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life.

Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.

WHAT TO DO IF YOU SMELL GAS

Do not try to light any appliance.

Do not touch any electrical switch; do not use any phone in your building.

Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.

If you cannot reach your gas supplier, call the fire department.

Installation and service must be performed by a qualified installer, service agency or the gas sup- plier.

UNVENTED GAS LOG HEATER OR VENTED DECORATIVE APPLIANCE

MODELS

VFDR18LB10N-1 VFDR18LB10P-1

VFDR18LBN-1 VFDR18LBP-1

VFDR24LBN-1 VFDR24LBP-1

VFDR30LBN-1 VFDR30LBP-1

VFDT18LBN-1 VFDT18LBP-1

VFDT24LBN-1 VFDT24LBP-1

VFDT30LBN-1 VFDT30LBP-1

VFDM18LBN-1 VFDM18LBP-1

VFDM24LBN-1 VFDM24LBP-1

VFDM30LBN-1 VFDM30LBP-1

EFFECTIVE DATE

JULY 2007

This is an unvented gas-fired heater. It uses air (oxy- gen) from the room in which it is installed. Provisions for adequate combustion and ventilation air must be provided. Refer to page 8.

WARNING: If not installed, operated and maintained in accordance with the manufacturer's instructions, this product could expose you to substances in fuel or from fuel combustion which can cause death or seri- ous illness.

WATER VAPOR: A BY-PRODUCT OF UN-VENTED ROOM HEATERS

Water vapor is a by-product of gas combustion. An unvented room heater produces approximately one (1) ounce (30ml) of water for every 1,000 BTU's (.3KW's) of gas input per hour. Refer to page 6.

23099-1-0707

Page 1

Image 1
Contents Installation Instructions Table of Contents Carbon Monoxide Poisoning MAY Lead to Death Important Safety InformationLP-GAS Warning Odor Safety Information for Users of LP-GASAccessories for VFDR, VFDT, & Vfdm Well Head Gas InstallationsAccessories for Vfdr only IntroductionModel BTU/hr Max. Rate Med. Rate Min. Rate Product SpecificationsBefore you get started General InformationMake sure you have received all parts High AltitudeGlass Doors ClearancesSidewall & Ceiling Clearances Figure Installing as a Vented ApplianceMantel Clearances Without Hood Figure Mantel Clearances with Hood FigureFireplace Preparation Combustible MaterialBefore Fully Installing the Appliance Installing AS a Vented ApplianceInstalling Damper Clamp Figure Pressure Testing of the Gas Supply System Installing a New Main Gas CockGAS Supply Recommended Gas Pipe DiameterEmber Material Placement on Burner VFDR,T,M18,24 & VFDR18LB10 LOG Placement 5 LOG SETEmber Material Placement on Burner VFDR,T,M30 LOG Placement 7 LOG SETMillivolt Valve for VFDR18LB10 Series Operation INSTRUCTIONS/FLAME AppearanceMillivolt Valve for Vfdr Series Thermostat Valve for Vfdt SeriesCheck System Operation Wiring Vfdr Models onlyRemote Receiver Millivolt SystemWhat to do if YOU Smell GAS VFDR18,24,30LB Lighting InstructionsVFDR18LB10N,P Lighting Instructions VFDT18,24,30LB Lighting Instructions VFDM18,24,30LB Lighting Instructions Incorrect Pilot Flame Pattern for Vfdr Pilot Flame CharacteristicsCorrect Pilot Flame Pattern for Vfdt & Vfdm Turn OFF Heater and Allow to Cool Before Cleaning Cleaning and ServicingHeater produces a whistling noise when main burner is lit Gas odor even when control knob is in OFF positionAppliance produces unwanted odors Appliance shuts off during use. Pilot stays onVfdr Series Parts List HOW to Order Repair PartsVfdr Series Parts View Index no Description VFDR18LB10 Parts ListVFDR18LB 10 Parts View Index Parts Numbers Description VFDT18LB VFDT24LB VFDT30LB Vfdt Series Parts ListVfdt Series Parts View Index Part Numbers Description VFDM18LB VFDM24LB VFDM30LB Vfdm Series Parts ListVfdm Series Parts View Service Notes