Hearth and Home Technologies 21M-ACC warranty Glass Replacement, When cleaning glass

Page 28

2100 Millennium Wood Stove (ACC)

R

 

CAUTION

 

Handle glass assembly with care.

Glass

When cleaning glass:

Assembly

• Avoid striking, scratching or

 

 

slamming glass.

•Do NOT clean glass when hot.

•Do NOT use abrasive cleaners.

•Use a hard water deposit glass cleaner on white film.

•Use commerical oven cleaner on heavier deposits.

•Remove all residue of oven cleaner or will permanently stain glass on next firing.

•

Refer to maintenance instructions.

B. Glass Replacement

1. Ensure that the fire is out and the appliance is cool to the touch.

2.Protect a table or counter top with padding or towels. Protect your hands and wear gloves to prevent injury.

3.Remove the door with the broken glass by lifting the door up and off of the hinges.

4.Lay door face down on a table or counter making sure the handle hangs over the edge so the door lays flat, on a soft surface.

5.Remove the screws from each glass retainer and remove the glass. (If screws are difficult to remove, soak with penetrating oil first).

6.Center the glass with edges evenly overlapping the opening in the door, (i.e. same space top and bottom, left and right sides).

7.Replace the glass retainers. Be careful not to cross thread the screws.

8.Tighten each retainer just a few turns until each is secured. Check again for centering of glass in door frame. Continue to tighten each retainer alternately, a few turns at a time, until the glass is secure. DO NOT OVERTIGHTEN.

9.Replace the door on the appliance.

Quadra-Fire stoves are equipped with ceramic super heat- resistant glass, which can only be broken by impact or misuse. Do not slam stove door or impact the glass. When closing door, make sure that logs do not protrude against the glass. Inspect glass regularly. If you find a crack or break, immediately put the fire out and return the door to your dealer for replacement of glass before further use.

WARNING

Handle glass with care.

• Inspect the gasket to ensure it is

Glassundamaged.

Assembly

•Do NOT strike, slam or scratch glass.

•Do NOT operate appliance with glass & door assembly removed.

•Do NOT operate with glass cracked, broken or scratched.

WARNING

Fire Risk.

Injury Risk.

•Use only glass specified in manual.

•DO NOT REPLACE with any other material. Glass breakage will occur.

Page 28

7039-131F

September 1, 2008

Page 27 Page 29
Image 28
Page 27 Page 29
Contents Hot glass will cause burns 7039-131F September 1Serial No Model Name Millennium Wood Stove ACCMfg. Date 7039-131F September 1 Table of Contents Appliance Certification BTU & Efficiency Specifications Glass SpecificationsListing and Code Approvals Mobile Home ApprovedFire Safety Getting StartedAppliance needs to draft properly for safety Millennium Wood Stove ACC Negative PressureMillennium Wood Stove ACC Flue Draft Considerations Venting SystemsTools And Supplies Needed Inspect Appliance & Components Pre-Use Check ListMillennium Wood Stove ACC Typical Stove Systems Masonry ChimneyDimensions and Clearances Appliance DimensionsInstallation InstallationR Hearth Protection RequirementsSee Figure USA required Canada recommendedItems Needed for Installation not supplied Millennium Wood Stove ACC Outside Air Kit InstallationFloor Installation Alternative In some instances you Millennium Wood Stove ACC Blower Optional Shock RiskChimney Connector Chimney RequirementsVenting Components Chimney Systems ThimbleComponents Air ClearancesInstructions Solid Pack Chimney with Metal Supports as a ThimbleInstalling Chimney Components Single wall connector or stove pipeSolid Pack Chimney with Metal Supports as a Thimble Cont’d Chimney Height / Rise and RunRule Millennium Wood Stove ACC Chimney Termination RequirementsPitched Roof Mobile Home Installation Door Handle Assembly Adjusting The Blower Speed Control Appliance Set-UpOperating Instructions Over-Firing Your Appliance Wood Selection & Storage Cont’dBurning Process Wood Selection & StorageAutomatic Combustion Control ACC Air ControlsBurn Rates and Operating Efficiency Millennium Wood Stove ACC Building a Fire Incorrect Positions Initial cold start-up and all Burn Settings Millennium Wood Stove ACC Blower Operating Instructions Opacity Smoke Snap Disc LocationOdor from appliance Millennium Wood Stove ACC Frequently Asked QuestionsAppliance General Maintenance Maintaining & Servicing Your ApplianceGlass Replacement When cleaning glassMillennium Wood Stove ACC Firebrick Replacement Correct Blanket & Baffle Position on Ceramic BlanketRemoving Tube Channel Assembly Millennium Wood Stove ACC Tube Channel Assembly ReplacementReplacing Tube Channel Assembly Troubleshooting Start Fire Problems Possible Cause SolutionReference Materials Exploded DrawingsSizes Blower Assembly Millennium Wood Stove ACC Service Parts & AccessoriesInch, 2 Nickel Hinge Pins and Nickel Quadra-Fire Logo RIVNUT-REPAIR Millennium Wood Stove ACC Service And Maintenance Log Date of Service Performed By Description of ServiceMillennium Wood Stove ACC Service And Maintenance Log Cont’d Millennium Wood Stove ACC Homeowner’s Notes Millennium Wood Stove ACC Homeowner’s Notes Cont’d CONDITIONS, Exclusions & Limitation of Liability 4021-645A This page is left blank intentionally Contact Information
Top Page Image Contents