Bradford-White Corp EF Series warranty What to do if YOU Smell GAS, With Troubleshooting Guide

Page 1

ULTRA HIGH EFFICIENCY COMMERCIAL GAS WATER HEATER

(EF Series Models)

Ambler, PA 19002

Tech. Service (800) 334-3393

Service Parts (800) 538-2020

Warranty Service (800) 531-2111

Part No. 238-44445-00B 03/04

WARNING: If the information in these instructions is not followed exactly, a fire or explosion may result causing property damage, personal injury or death

-Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance

-WHAT TO DO IF YOU SMELL GAS

Do not try to light any appliance.

Do not touch any electrical switch; do not use any phone in your building.

Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.

If you cannot reach your gas supplier, call the fire department.

-Installation and service must be performed by a qualified installer, service agency or gas supplier

INSTALLATION/OPERATING MANUAL

WITH TROUBLESHOOTING GUIDE

PLACE THESE INSTRUCTIONS ADJACENT TO WATER HEATER AND NOTIFY OWNER TO KEEP FOR FUTURE REFERENCE

Image 1
Contents What to do if YOU Smell GAS With Troubleshooting GuideTable of Contents Page Do not Operate the Appliance Until the Leakage is Corrected If YOU Smell GASSection SpecificationsSection III General Information FeaturesTemperature and Pressure Relief Valve Condensate Elbow With Loop Dishwashing Machine RequirementsSection IV Installation Instructions Minimum Clearance To Combustible UnpackingRemove Crate LocationAIR Requ Rements Unconfined Space Mechanical Exhausting of Room AIRConfined Space Chemical Vapor CorrosionTypical Front Inlet Connection Typical Installation IllustrationTypical Two Water Heater Connection Instructions for Connections Section V Water ConnectionsScalding Approximate TIME/TEMPERATURE Relationships in ScaldsAlternate Space Heating Connections Alternate Space Heating Water ConnectionsSection VI Venting Typical Plumbing Schematic for Zoned HeatingVenting Direct Vent InstallationExceptions for Installations Page Typical Horizontal Direct Vent System Typical Vertical Direct Vent System Installation Direct Vent Maximum Vent Length Power Vent InstallationTypical Horizontal Power Vent System Typical Vertical Power Vent System Installation Coaxial Venting Installation Procedure Power Vent Maximum Vent LengthDimensional Layout of Concentric Vent Kit Concentric Vent Roof Top Attachment Initial Preparation Vent Pipe PreparationSelection of Materials Section VII GAS ConnectionsGAS Pressure Regulation GAS Meter Size Natural Gases onlySection Viii Electrical Connections Wiring Diagram and SchematicGeneral Instructions Section IX Operating InstructionsTo Fill the Water Heater Sequence of OperationLighting Instructions Temperature Adjustm NTSight Glass Location Burner Flame CheckMaintenance Schedule Section X MaintenanceGeneral Draining Water Heater Flushing Water HeaterFilling Water Heater Sediment and Lime Scale RemovalDrain Valve and Tank Access Panel Anode Inspection and ReplacementRelief Valve Combustion System Inspection Vent and AIR Intake SystemReference Section XI Troubleshooting GuideIs there continuity across the Hot Surface Ignitor? If EF Series Water Heater Section XI Parts ListCombustion Surround Assy CC Ignition Control Assy