Honeywell Central Heating Cooker Natural Gas General Description, Health and Safety at Work Act

Page 19

INSTALLATION INSTRUCTIONS

1.GENERAL DESCRIPTION

1.1The Redfyre range of Central Heating cookers is a range of floor mounted storage central heating cookers with a fixed rate cooker burner and the option of four fixed rate central heating outputs depending on heating load. 60, 80, 100 x 12,000 BTU.

1.2The cooker has two independent matched premix gas burners which are exceptiantly quiet in operation. One heats the cooker and the other the central heating and are controlled via thermostats with the cooker being controlled bu an electronic programmer within the unit

1.3The boiler side of the cooker has been designed for use on open vent or sealed systems. If it is to be used on a sealed water system up to a maximum working pressure of 3bar, additional safety devices will be required.

1.4This cooker is suitable for use on natural gas only and must be connected to a conventional flue.

1.5Incorporated with the appliance are:-

a)User adjustable controls for cooking oven and central heating water temperature.

b)Burner running indicator neons

c)Overheat thermostats (with neon indicators) on both the cooker and boiler, with an additional pump over run thermostat on the central heating circuit.

d)An integral electronic programmer to control the cooker on and off times.

e)A boiling spot and simmer spot in addition to a top oven (with thermostat control) and a separate lower oven which operates at approximately 100° C lower than the top oven

f)A blocked flue thermostat which prevents the unit operating if a blocked flue occurs.

g)Two efficient and quiet premix gas burners with fully

automatic ignition provide outputs with very Low NoX values.

1.6All servicing can be carried out from the front and top of the appliance, thus allowing the cooker to be fitted between kitchen units. The front mounted flue-cover permits easy access for the removal of the flue baffles and cleaning of heating surfaces.

1.7This appliance has been designed to conform to European Directive/Standards BED, LVD, EN, EMC and GAD.

1.8The installation of this central heating cooker MUST be carried out by a competent person in accordance with the relevant requirements of the current issue of the Gas Safety (Installation and Use) Regulations, the Building Regulations, the IEE Wiring Regulations, the Building Standards (Scotland) Regulations (applicable in Scotland), Local Water Company Byelaws, Health and Safety Document No 635.

Detailed recommendations are contained in the current issues of the following British Standards BS 5440 Pts 1 & 2, BS 5449, BS 5546, BS 6700, BS 6798, BS 6891 and BS 7593.

1.9Health and Safety at Work Act

The installer should be aware of his responsibilities under the Act and provide, where necessary, appropriate protection for persons carrying out the installation.

19

Page 18 Page 20
Image 19
Page 18 Page 20
Contents Central Heating Cooker GLUES, Sealants & Paint Health and SafetyInformation for the Installer and Service Engineers Insulation and SealsDo not Cover the Outlet on the TOP Rear Splash Back Cover General Safety InstructionsServicing Instructions ContentsInstallation Instructions User InstructionsImportant Customer Notice Important InformationHotplates Users InstructionsMain Oven Lower OvenCooker Burner Switching OFFLighting the Burners Programmer -COOKERCentral Heating Blocked Flue Approx Time Top Oven Bottom Oven HotplateCasseroles Oven Cooking GuideMeat PoultryUses for the Programmer PastriesCold Start Cooking Care of the Cooker User Cooker Fault Finding User Boiler Fault Finding Enamelled Parts on your cooker Step by step guide to reporting a fault with your applianceCharge will be made where Please NoteTechnical Details AIR Supply and Ventilation Site RequirementsOverlap the Black Enamel TOP Plate Central Heating Cooker Dimensions General Description Health and Safety at Work ActTypes of Chimney and Flue Systems InstallationGAS Supply Flue & Chimney RequirementsRigid Stainless Steel Flue Pipe Lining of Existing ChimneysFlue Pipes Flexible Stainless SteelRoof Pitch Over Flat Roof Flue SystemsWind Effects on Buildings High LOW Important NotesRecommended flue positions for some roof conditions Flue TerminationWater Systems Plumbing ‘Y’ Plan Open SystemsPlumbing ‘S’ Plan Cable Fixing Gland Electrical SupplyCooker Internal Wiring Wiring ‘S’ Plan Wiring ‘Y’ Plan Servicing Replacement of PartsBoiler Burner Removal Ionisation Electrode Removal Cooker BurnerIgnition & Ionisation Electrodes Ignition Electrode RemovalCooker Thermostats Boiler ThermostatsCooker Programmer Service Procedures for Burners Burner Reset SwitchesBlocked Flue Overheat Themostat Boiler Heat Exchanger Failure to do SO will Enable Flue Gases to Enter the RoomCooker Flueways Guide to Fault Finding Service EngineerYES Fault Finding Not Shown Spare Parts BurnerSpare Parts List Exploded View 29 30 31Page Page Division of Gazco Limited

Central Heating Cooker Natural Gas specifications

The Honeywell Central Heating Cooker powered by natural gas is a prime example of modern kitchen technology, seamlessly blending efficiency, convenience, and safety features to create an exceptional cooking experience. With Honeywell's years of expertise in heating solutions, this cooker is designed to provide not only a reliable cooking tool but also an efficient heating source for your home.

One of the standout features of the Honeywell Central Heating Cooker is its efficient natural gas operation. Utilizing natural gas ensures that the cooker operates at a lower cost compared to electric models, making it an economical choice for households. The heat produced by natural gas is immediate, allowing for faster cooking times and better temperature control, ensuring that meals are prepared quickly and to precise specifications.

The cooker incorporates advanced heating technologies, including uniform heat distribution that minimizes hot spots and ensures even cooking across pans. This is particularly beneficial when preparing complex dishes that require different cooking techniques simultaneously. The integrated thermostat monitors the cooking temperature in real-time, allowing for perfect results every time.

In terms of safety, the Honeywell Central Heating Cooker is equipped with multiple safety mechanisms. An automatic shut-off feature provides peace of mind, especially for busy households. This is complemented by flame failure devices that detect if the flame goes out unexpectedly, cutting off the gas supply to prevent potentially hazardous situations.

The design of the Honeywell cooker is also user-friendly, offering intuitive controls that make it easy to adjust the settings as needed. The model features spacious cooking surfaces with multiple burners, accommodating various pot and pan sizes while optimizing workspace in the kitchen. Additionally, the sleek stainless steel finish not only looks modern but is also easy to clean.

Furthermore, energy efficiency is a key characteristic of the Honeywell Central Heating Cooker. It adheres to stringent energy standards, helping users reduce their carbon footprint while also saving on energy costs. This combination of efficiency, safety, and performance sets Honeywell apart as a leader in cooking appliances.

Ultimately, the Honeywell Central Heating Cooker is not just a cooking appliance; it represents a harmony of functionality, safety, and innovation. Whether you are a professional chef or a home cook, this cooker promises to elevate your cooking experience while also providing an efficient heating solution for your home.
Top Page Image Contents